Blitz TWIN Logos Instrucciones Para El Manejo página 13

IMPORTANT INFORMATION
Read and understand all of the operating instructions, safety precau-
tions and warnings in the Instruction Manual before operating or
maintaining this compressor.
Most accidents that result from compressor operation and mainte-
nance are caused by the failure to observe basic safety rules or pre-
cautions.
An accident can often be avoided by recognizing a potentially haz-
ardous situation before it occurs, and by observing appropriate safety
procedures.
Basic safety precautions are outlined in the "SAFETY" section of this
Instruction Manual nad in the sections which contain the operation
and maintenance instructions.
Hazards that must be avoided to prevent bodily injury or machine
damage are identified by WARNINGS on the compressor and in this
Instruction Manual.
Never use this compressor in a manner that has not been specifically
recommended by manufacturer, unless you first confirm that the
planned use will be safe for you and others.
MEANINGS OF SIGNAL WORDS
WARNING: indicates a potentially hazardous situations which, if ig-
nored, could result in serious personal injury.
CAUTION: indicates a hazardous situations which, if ignored, couls
result moderate personal injury, or could cause machine damage.
NOTE: emphasizes essential information
SAFETY
IMPORTANT SAFETY INSTRUCTIONS FOR USE OF THE COM-
PRESSOR.
WARNING:
DEATH OR SERIOUS BODILY INJURY COULD RESULT FROM
IMPROPER OR UNSAFE USE OF COMPRESSOR. TO AVOID
THESE RISKS, FOLLOW THESE BASIC SAFETY INSTRUCTIONS.
READ ALL INSTRUCTIONS
1. NEVER TOUCH MOVING PARTS
Never place your hands, fingers or other body parts near the com-
pressor's moving parts.
2. NEVER OPERATE WITHOUT ALL GUARDS IN PLACE
Never operate this compressor without all guards or safety features in
place and in proper working order. If maintenance or servicing re-
quires the removal of a guard or safety features, be sure to replace
the guards or safety feature before resuming operation of the com-
pressor.
3. ALWAYS WEAR EYE PROTECTION
Always wear safety goggles or equivalent eye protection.
Compressed air must never be aimed at anyone or any part of the
body.
4. PROTECT YOURSELF AGAINST ELECTRIC SHOCK
Prevent body contact with grounded surfaces such as pipes, radia-
tors, ranges and refrigeration enclosures. Never operate the com-
pressor in damp or wet locations.
5. DISCONNECT THE COMPRESSOR
Always disconnect the compressor from the power source and re-
move the compressed air from the air tank before servicing, inspect-
ing, maintaining, cleaning, replacing or checking any parts.
6. AVOID UNINTENTIONAL STARTING
Do not carry the compressor while it is connected to its power source
or when the air tank is filled with compressed air. Be sure the knob of
the pressure switch in the "OFF" position before connecting the com-
pressor to its power source.
7. STORE COMPRESSOR PROPERLY
When not in use, the compressor should be stored in dry place.
Keep out of reach of children. Lock-out the storage area.
8. KEEP WORK AREA CLEAN
Cluttered areas invite injurues. Clear all work areas of unnecessary
tools, debris, furniture etc...
9. KEEP CHILDREN AWAY
Do not let visitors contact compressor extension cord. Alla visitors
should be kept safely away from work area.
10. DRESS PROPERLY
Do not wear loose clothing or jewerly. They can be caught in moving
parts. Wear protective hair covering to contain long hair.
11. DON'T ABUSE CORD
Never yank it to disconnect from receptable. Keep cord from heat, oil
and sharp edges.
12. MAINTAIN COMPRESSOR WITH CARE
13
Follow instructions for lubricating. Inspect cords periodically and if
damaged, have repaired by authorized service facility.
Inspect extension cords periodically and replace if damaged.
13. OUTDOOR USE EXTENSION CORDS
When compressor in used outdoors, use only extension cords in-
tended for use outdoors and so marked.
14. STAY ALERT
Watch what you are doing. Use common sense. Do not operate
compressor when you are tired.
Compressor should never be used by you if you are under the influ-
ence of alcohol, drugs or medication that makes you drowsy.
15. CHECK DAMAGED PARTS AND AIR LEAK
Before further use of the compressor, a guard or other part is dam-
aged should be carefully checked to determine that it will operate
properly and perform its intended function.
Check for alignment of moving parts, binding of moving parts, break-
age of parts, mounting, air leak, and any other conditions that may
affect its operation.
A guard or other part that is damaged should be properly repaired or
replaced by an authorized service center unless otherwise indicated
elsewhere in this Instruction Manual. Have defective pressure
switches replaced by authorized service center. Do not use compres-
sor if switch does not turn it on and off.
16. HANDLE COMPRESSOR CORRECTLY
Operate the compressor according to the instructions provided here-
in. Never allow the compressor to be operated by children, individuals
unfamiliar with its operation or unauthorized personnel.
17. KEEP ALL SCREWS, BOLTS AND COVERS TIGHTLY IN
PLACE
Keep all screws, bolts, and plates tightly mounted.
Check their condtions periodically.
18. KEEP MOTOR AIR VENT CLEAN
The motor air vent must be kept clean so that air can freely flow at all
times. Check for dust build-up frequently.
19. OPERATE COMPRESSOR AT THE RATED VOLTAGE
Operate the compressor at voltages specified on their nameplates. If
using the compressor at a higher voltage than the rated voltage, it will
result in abnormally fast motor revolution and mey damage the unit
and burn out the motor.
20. NEVER USE A COMPRESSOR WHICH IS DEFECTIVE OR
OPERATING ABNORMALLY
If the compressor appears to be operating unusually, making strange
noises, or otherwise appears defective, stop using it immediately and
arrange for repairs by a authorized service center.
21. DO NOT WIPE PLASTIC PARTS WITH SOLVENT
Solvents such as gasoline, thinner, benzine, carbon tetrachloride,
and alcohol may damage and crack plastic parts. Do not wipe them
with such solvents. Wipe plastic parts with a soft cloth lightly damp-
ened with soapy water and dry thoroughly.
22. USE ONLY GENUINE REPLACEMENT PARTS
Replacement parts not original may void your warranty and can lead
to malfunction and resulting injuries. Genuine parts are available from
your dealer.
23. DO NOT MODIFY THE COMPRESSOR
Do not modify the compressor. Always contact the authorized service
center any repairs. Unauthorized modification may not only impair the
compressor performance but may also result in accident or injury to
repair personnel who do not have the required knowledge and tech-
nical expertise to perform the repair operations correctly.
24. TURN OFF THE PRESSURE SWITCH WHEN THE COMPRES-
SOR IS NOT USED
When the compressor is not used, turn the knob of the pressure
switch OFF, disconnect it from the power source and open the drain
cock to discharge the compressed air from the air tank.
25. NEVER TOUCH HOT SURFACE
To reduce the risk of burns, do not touch tubes, heads, cylinder and
motors.
26. DO NOT DIRECT AIR STREAM AT BODY
Risk of injury, do not direct air stream at persons or animals.
27. DRAIN TANK
Drain tank daily or after 4 hours of use.
Open drain fitting and tilt compressor to empty accumulated water.
28. DO NOT STOP COMPRESSOR BY PULLING OUT THE PLUG
Use the "AUTO/OFF" knob of pressure switch.
29. USE ONLY RECOMMENDED AIR HANDLING PARTS
ACCEPTABLE FOR PRESSURE NOT LESS THAN 125 PSI (8.6
BAR)
GB