Prestolite Performance Mr. Gasket 12D Instrucciones De Instalación

MR. GASKET (MICRO) ELECTRIC FUEL PUMPS #12D
• Works great for fuel transfer systems in diesel applications.
• NOT FOR FUEL INJECTION SYSTEMS.
• Not recommended for any type of aircraft or marine application.
• The Mr. Gasket Diesel Fuel Pump is a self priming pump with
simple two bolt and two wire installation, with extremely
low amp draw. (Average 2 amps at maximum delivery).
• This diesel pump is efficient at pushing fuel. (Never install to
pull fuel).
Pump Mounting:
Locate a pump position about 12'' from the fuel tank and as
close to the lowest level of the tank to ensure proper fuel
supply. Clean mounting area by removing all rust paint and
grease, surface should have a shiny appearance when correctly
done. Use the pump mounting bracket as a template, drill two
7/32'' holes. Next use the supplied self tapping bolts and star
washers to secure the pump, and ground lead to the frame.
Always use a location that enables you to add the safety nuts
provided. Install the supplied filter in the pump inlet and out-
let using thread sealing tape, tighten to 10-ft-lbs.
Now install the inline filter and hose to the inlet side of the
pump using automotive quality hose clamps. Always replace
hose with approved fuel line. This pump is for negative ground
systems only! Make sure to use the red lead for 12 volt
power and the black lead for ground! Remember the ground
lead connection is just as important as the positive lead.
The RED positive lead needs to be connected to switched
ignition terminal. Make sure a 5 amp fuse or in-line fuse holder
is utilized. Use only quality automotive grade electrical cable,
minimum of 16 gauge, 14 gauge if wire run is over 20 feet.
Ensure that all connections are secured with a good solder or
quality crimp-type connector. Be sure connections are sealed
from the elements. Finally, protect the cable from abrasion
with Mr. Gasket part number 4500.
Inspect for fuel leaks. If leaks are detected re-tighten clamps. Check
pump and fuel line connections and filter. Remember an electric fuel
pump is very efficient pushing fuel, it's very inefficient at pulling fuel,
always locate the pump nearest to the fuel supply as possible.
MR. GASKET
LIMITED NINETY (90) DAY WARRANTY
Prestolite Performance which includes ACCEL, Hays, Lakewood,
Mallory and Mr. Gasket product lines, warrants its products only to
the original purchaser at retail to be free from defects in material and
workmanship for a period of 90 days from the date of original retail
purchase, except that the following products have longer warranty periods:
WHO IS COVERED:
The warranty extends to original purchaser at retail only, with a proof
of purchase.
WHAT IS COVERED:
All parts which are defective in materials or workmanship on original
installation only, subject to the following:
WHAT IS NOT COVERED:
1. Products which have been subjected to abuse, accident, alteration,
modification, improper installation, improper operational adjustments,
tampering, negligence, misuse, or if repaired or serviced by anyone
other than Mr. Gasket.
2. Actual or alleged labor, transportation or other incidental charges.
3. Actual or alleged consequential damages incurred by use of this product.
WHAT WE WILL DO:
Mr. Gasket at its election, will either repair or replace all defective
parts free of charge.
WHAT YOU MUST DO FOR THE WARRANTY SERVICE:
In the event that the original purchaser detects a defect in the material
or workmanship, the product(s) in question must be returned by the
original retail purchaser to the place of original purchase for warranty
determination. In the event that the purchaser does not receive
satisfaction from the place of original purchase or in the event there
are any questions with regard to this limited warranty, please contact
the Technical Service Dept., Mr. Gasket, 10601 Memphis Ave., #12,
Cleveland, OH 44144, or call (216) 688-8300 ext. 5.
Do not send alleged defective parts to Mr. Gasket without prior
approval to do so. If such approval is obtained, the defective part and
proof of purchase should be sent, postage prepaid, to Mr. Gasket, at
the above address.
NO OTHER WARRANTY, EXPRESS OR IMPLIED, IS APPLICABLE TO THE
PRODUCTS OR MR. GASKET.
THE DURATION OF ANY IMPLIED WARRANTIES, INCLUDING THE
IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR
A PARTICULAR PURPOSE, IS LIMITED TO THE DURATION OF THE
EXPRESS WARRANTY HEREIN. MR. GASKET SHALL NOT BE LIABLE
FOR THE LOSS OF USE OF THE PRODUCT, INCONVENIENCE, LOSS
OR ANY OTHER DAMAGES, DIRECT OR CONSEQUENTIAL, ARISING
OUT OF THE USE OF, OR INABILITY TO USE, THE PRODUCT OR
FOR ANY BREACH OF ANY EXPRESS OR IMPLIED WARRANTY,
INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY
AND FITNESS FOR A PARTICULAR PURPOSE APPLICABLE TO THIS
PRODUCT.
Some states do not allow the exclusion or limitation of incidental or
consequential damages or limitations on how long an implied war-
ranty lasts, so these limitations or exclusions may not apply to you.
This warranty gives you specific legal rights and you may also have
other rights which vary state to state.
Materials, components, specifications, colors, model changes,
availability and prices are subject to change without notice or obligation.
Manufacturers' brand names, trademarks and registered trademarks
are used for reference only and are not to imply that any product is
of their manufacture or any association herewith.
Mr. Gasket, makes no representation or warranty, express or implied,
that its products comply with local, State or Federal emission levels,
noise levels or safety standards. The purchaser assumes all responsi-
bility for such use and compliance.
Mr. Gasket is a trademark of Prestolite Performance
Cleveland, OH
www.mr-gasket.com 01/12