Publicidad
1. DEtErMInE A SuItABlE locAtIon
It's very important that you consider the most suitable location for your sail. Take into account the following:
A. Size of the sail.
b. Strength of the existing structures intended to be anchoring points.
C. Possibility to insert fixing posts.
D. Location of barbecues, sun direction, high wind areas, electrical / telephone cables, water pipes, etc.
2. DEtErMInInG AncHorInG / FIXInG poIntS
Once the location is chosen, it is important to determine the most suitable fixing points for the sail's corners
(e.g. a pergola, sundeck, large tree, fence post or fascia).
This stage of installation is critical! Ensure all fixing points are structurally sound and if uncertain, obtain
independent advice from a technician or engineer. A fixing height of at least 8 ft. is recommended.
Lay out the sail in a large open space to determine suitable fixing points. Allow a minimum of an ad-
ditional 10% of the sail's length between each fixing point and the sail's corner ring for the tensioning device
(turnbuckle). See Diagram A.
If you have a 12-ft. Sail: 10% = 14.5 inches
Attaching to a fascia: The use of a fascia support is strongly recommended. A fascia support connects the
overhangs of rafters or trusses and is available from your local hardware store. See Diagram B.
Attaching to trees: Attach the sail to trees temporarily only. The recommended diameter of the tree should
be at least 10 inches.
3. AttAcHInG tHE SAIl
The hardware enclosed is suitable for most common fixing points. Additional hardware such as D-shackles,
pad-eyes, S-hooks, snap hooks, strap tensioners, etc. are available at your local hardware store. Attach the
hardware to the mounting points as required, facing towards the middle of the sail (see Diagram C). Secure
tightly. See Diagram D for a sample configuration.
4. tEnSIon
Connect all points and pre-tension the sail by hand at first. Complete the tension by using the turnbuckle.
Stop increasing the tension when the sail becomes rigid and little or no fold marks are visible. Do not over-
tighten the sail.
Dia. A
Minimum 10%
of sail length
Fixing
Point
Dia. D
Fixing
Points
Minimum 10%
of sail length
Turnbuckle
Eyebolt
If you have a 16-ft. Sail: 10% = 19.25 inches
Sail
Dia. b
Dia. C
Nylon Rope
Rope Clips
Page 4
Fascia
Rafter
or Truss
Fascia
Support
Corner
Shade
Ring
Sail
05_25720_25721_25733_25734_0A
Publicidad
