Safety Precautions; Maintenance Schedule; Refueling - Honda GX630 Manual Del Propietário

SAFETY PRECAUTIONS

Make sure the engine is off before you begin any maintenance
or repairs. To prevent accidental startup, disconnect the spark
plug cap. This will eliminate several potential hazards:
−
Carbon monoxide poisoning from engine exhaust.
Operate outside, away from open windows or doors.
−
Burns from hot parts.
Let the engine and exhaust system cool before touching.
− Injury from moving parts.
Do not run the engine unless instructed to do so.
Read the instructions before you begin, and make sure you have
the tools and skills required.
To reduce the possibility of fire or explosion, be careful when
working around gasoline. Use only a non-flammable solvent,
not gasoline, to clean parts. Keep cigarettes, sparks and flames
away from all fuel related parts.
Remember that an authorized Honda servicing dealer knows your
engine best and is fully equipped to maintain and repair it.
To ensure the best quality and reliability, use only new Honda
Genuine parts or their equivalents for repair and replacement.

MAINTENANCE SCHEDULE

REGULAR SERVICE PERIOD (3)
Perform at every
indicated month or
operating hour interval,
whichever comes first.
ITEM
Engine oil Check level
Change
Engine oil filter Replace
Air cleaner Check
Clean
Replace
Spark plug Check-adjust
Replace
Spark arrester Clean
( applicable types )
Idle speed Check-adjust
Valve clearance Check-adjust
Combustion Clean
chamber
Fuel filter Replace
Fuel tube Check
＊ Replace the paper filter element only.
＊＊ Refer to the Shop Manual.
(1) Service more frequently when used in dusty areas.
(2) These items should be serviced by your Honda servicing
dealer, unless you have the proper tools and are mechanically
proficient. Refer to the Honda shop manual for service
procedures.
(3) For commercial use, log hours of operation to determine
proper maintenance intervals.
Failure to follow this maintenance schedule could result in non-
warrantable failures.
Each First Every 6 Every Every 2
Use Month Months Year Years
or or or
20 Hrs 100 Hrs 300 Hrs 500 Hrs
Every 200 Hrs.
(1)
(2)
(2)
After every 1000 Hrs. (2)
(2)
Every 2 years (Replace if necessary) (2)

REFUELING

Recommended Fuel
Unleaded gasoline
U.S.
Except U.S.
This engine is certified to operate on unleaded gasoline with a
pump octane rating of 86 or higher (a research octane rating of 91
or higher).
Refuel in a well ventilated area with the engine stopped. If the
engine has been running, allow it to cool first. Never refuel the
engine inside a building where gasoline fumes may reach flames
or sparks.
You may use unleaded gasoline containing no more than 10%
ethanol (E10) or 5% methanol by volume. In addition, methanol
must contain cosolvents and corrosion inhibitors. Use of fuels
with content of ethanol or methanol greater than shown above
may cause starting and/or performance problems. It may also
damage metal, rubber, and plastic parts of the fuel system. Engine
damage or performance problems that result from using a fuel
with percentages of ethanol or methanol greater than shown
above are not covered under the Warranty.
If your equipment will be used on an infrequent or intermittent
basis, please refer to the fuel section of the STORING YOUR
ENGINE chapter (see page
regarding fuel deterioration.
Refer
to
or Page
Gasoline is highly flammable and explosive, and you
can be burned or seriously injured when refueling.
8
8
Stop the engine and keep heat, sparks, and flame
9
away.
9
Refuel only outdoors.
9
Wipe up spills immediately.
＊
10
11
Fuel can damage paint and some types of plastic. Be careful not to
＊＊
spill fuel when filling your fuel tank. Damage caused by spilled
＊＊
fuel is not covered under the Distributor's Limited Warranty.
＊＊
Never use stale or contaminated gasoline or an oil/gasoline
＊＊
mixture. Avoid getting dirt or water in the fuel tank.
＊＊
With the engine stopped and on a level surface, remove the fuel
filler cap and check the fuel level. Refill the tank if the fuel level is
low.
Refer to the instructions provided with the equipment powered by
this engine for refuelling.
Refuel in a well-ventilated area before starting the engine. If the
engine has been running, allow it to cool. Refuel carefully to avoid
spilling fuel. It may be necessary to lower the fuel level depending
on operating conditions. After refueling, tighten the fuel tank cap
securely.
Keep gasoline away from appliance pilot lights, barbecues,
electric appliances, power tools, etc.
Spilled fuel is not only a fire hazard, it causes environmental
damage. Wipe up spills immediately.
ENGLISH
Pump octane rating 86 or higher
Research octane rating 91 or higher
Pump octane rating 86 or higher
11 ) for additional information
7