Before Returning For Repairs; Replacement Parts/Accessories - Schumacher DSR116 Manual Del Usuario

Charger
PROBLEM
The green Power LED does
not light when charger is
properly connected.
The red Bad Battery LED is lit. The battery is sulfated.
The red Bad Battery LED
is lit and the yellow/orange
Charging Status LED is
flashing rapidly.

10. BEFORE RETURNING FOR REPAIRS

For information about troubleshooting, contact customer service for assistance:
services@schumacherelectric.com | www.batterychargers.com | or call 1-800-621-5485
For REPAIR OR RETURN, contact Customer Service at 1-800-621-5485. DO NOT SHIP UNIT until
you receive a RETURN MERCHANDISE AUTHORIZATION (RMA) number from Customer Service
at Schumacher Electric Corporation.

11. REPLACEMENT PARTS/ACCESSORIES

Male-to-male accessory cable ..................................................................................................94500109
Charger .............................................................................................................................. 2299003063Z
Replacement battery .......................................................................................................... 5799000010Z
REASON
AC outlet is dead.
Poor electrical connection.
Lack of progress is detected and
battery voltage is below 14.2V.
The battery's initial voltage is below
12.2V and the total input is less than
1.5 Ah.
The battery voltage drops below
12.2V during Maintain Mode.
The battery voltage is still below 10V
after 2 hours of charging.
(or)
In maintain mode, the output current
is more than 1.5A for 12 hours.
Desulfation was unsuccessful.
• 14 •
SOLUTION
Check for open fuse or circuit breaker
supplying AC outlet.
Check power cord and extension cord
for a loose fitting plug.
The charger is in desulfation mode.
Continue charging for several hours.
If not successful, have the battery
checked.
The battery may be overheated. If so,
allow the battery to cool. The battery may
be too large or have a short circuit. Have
battery checked or replaced.
The battery capacity is too low, or the
battery is too old. Have it checked or
replaced.
The battery won't hold a charge. May
be caused by a drain on the battery or
the battery could be bad. Make sure
there are no loads on the battery. If
there are remove them. If there are
none, have the battery checked or
replaced.
The battery may be defective. Make
sure there are no loads on the battery.
If there are, remove them. If there are
none, have the battery checked or
replaced.
The battery may be defective. Have
battery checked or replaced.