Maintenance; Filter; Batteries Of The Remote Controller; Bolt Check - Webasto Cool Top Trail 35 Instrucciones De Funcionamiento E Instalación

6

Maintenance

6.1

Filter

Fig. 42: Air filter
6.2 Batteries of the Remote Control
Fig. 43: Remote Control battery change
6.3

Bolt check

Check the four bolts holding the unit to the roof for tightness 3 months after the first installation of the prod-
X
uct.
Inspect these bolt regularly every 12 months. Retighten to 7 Nm if necessary.
X
6.4

Regular usage

It is recommended that the air conditioner is operated regularly to ensure good performance.
Run the unit at least for 20-30 min. every 6 months.
X
6.5

Cleaning

Regularly remove leaves or other dirt from the ventilation grilles of the outdoor unit.
X
Regularly clean the unit with a soft, damp cloth and mild detergent.
X
Clean the vehicle roof at regular intervals. A dirty roof heats up more than a clean roof.
X
CAUTION
■ Never drive through automatic car washes with a roof air conditioner installed.
■ Do not spray into the openings of the unit with a high-pressure cleaner.
■ Do not use hot cleaners and steam cleaners.
■ Do not use sharp or hard objects for cleaning.
■ Never use petrol, diesel, solvents or agressive cleaning agents.
6.6

Heat exchangers

Once per year have the heat exchangers cleaned by a specialist workshop.
Cool Top Trail 35
The return air filter needs periodic maintenance.
Check and clean the filters each week when in use to pre-
X
vent the filters from being blocked by dirt.
The filters should be washed frequently to ensure effective
X
cooling and heating.
Pull out the filter from the air distributor before washing
X
them in warm water with a touch of detergent.
NOTE
■ Replacement filters can be ordered separately.
■ Never operate the air conditioner without a fil-
ter. This can cause fouling of the heat exchang-
er and lead to a loss of power.
Change the remote control batteries (2xAAA type) when the
display of the remote control becomes unreadable and/or
blurry.
Do not dispose of any batteries with general
household waste. Return defective or used bat-
teries to your retailer or dispose of them at a col-
lection point.
NOTE
Remove the batteries from the remote control if
the remote control is not used for a long time to
prevent damage to the remote control from
leaking batteries.
22