Publicidad
Idiomas disponibles
Idiomas disponibles
SECTION 1.0 WARNINGS:
involved with the safe installation and operation of these products. Even if you feel you are familiar with
this or similar equipment, you should read this manual before operating the product.
AMH recognizes that most companies who use hoists have a safety program in force in their plants. In
the event you are aware that some conflict exists between a rule set forth in this publication and a similar
rule already set by an individual company, the more stringent of the two should take precedence. Safe
Operating Instructions are provided to make an operator aware of unsafe practices to avoid and are not
necessarily limited to the following list. Refer to specific sections in the manual for additional safety
information.
WARNING
1. Only allow people, trained in safety and operation of this product, to
operate the hoist.
2. Only operate a hoist if physically fit to do so.
3. After use, or in a non-operational mode the hoist should
be secured against unauthorized use
4. When a "DO NOT OPERATE" sign is placed on the hoist,
do not operate until the sign has been removed by
designated personnel.
5. Periodically, inspect the hoist thoroughly and replace worn or
damaged parts. (See 2.0 INSPECTION and TEST)
6. Before use ensure that attachment points and supporting
structure are adequate. If in doubt consult a qualified
professional.
7. Always visually inspect the hoist for wear or damage by
operator before each use
8. Always check that the load is seated in the saddle of the
hook and the hook latch is engaged.
9. Always pay attention to the load and surroundings when
operating.
10. Always ensure that the operator and all other people are clear
of the path of the load.
11. Do Not use a hoist which inspection indicates is worn or
damaged.
12. Do not use if hook latch has been sprung, broken or
missing.
13. Do not support the load on the tip of the hook.
14. Do Not place your hand inside the throat area of a hook.
15. Do Not use the hoist load chain as a sling.
16. Do not operate hoist if chain jumping, excessive noise,
jamming, or binding occurs.
17. Do not force a chain or hook into place by hammering.
18. Do not allow the load chain to run over a sharp edge.
19. Do Not allow anyone to stand on a suspended load.
20. Do Not swing a suspended load.
21. Do Not use the hoist chain as an electric welding ground.
22. Do Not leave a load suspended when hoist is unattended.
23. Do Not operate if restricted in forming a straight line
between hooks.
24. Do Not operate with other than manual power.
25. Do Not operate with a twisted, kinked, or damaged chain.
26. Do Not operate a damaged or malfunctioning hoist.
27. Do Not lift people or loads over people
28. Do Not lift more than WLL (Working Load Limit)
MAN-AMH-MA-07
This manual provides important information for all personnel
- 2
To avoid serious
injury or death
Copyright © 2007 by
© 2018 AMH
:
TM
AMH
Publicidad
