Pramac Powermate PMD5000s Manual Del Usuario página 11

OPERATING THE DIESEL GENERATOR
DO NOT fill engine oil when the machines are running.
2-2.3 Checking the air filter
(1) Open the cover of generators, you will
see the air filter assembly.
(2) Loosen the butterfly nut of air filter,
take the cover of the air filter off and take
the air filter element out.
NOTE
Do not use detergent to wash the air filter element.

When the performance of the engine decreases or when the color of the

exhaust gases is bad, exchange the filter element.
Never start the engine without the air filter as foreign objects may enter the

intake and damage the engine.
(3) After replacing the air filter element, replace the cover and tighten the
butterfly nut firmly.
If not replace the air filter immediately, the dust in the air will not be adsorbed.
In that case, it stands a good chance to block the air way.
2-2.4 Check the oil way
The fuel and oil in a new engine is drained before sold. Before you start the
engine, please fill the fuel tank and engine oil first. Then, check to see if there
are air bubbles in the engine. If there are, follow these procedures. Loosen the
connecting nut between the oil injection pump and oil pipe. Bleed the air from
the system until there are no more bubbles. Then replace the connecting nut
and tighten it.
2-2.5 Check the generators
(1) Close the power switch and disconnect from any load. Otherwise it may
cause electric shock. Even make injures or death.
WARNING
Make sure to close the power switch.
Make sure to ground the generators.
(2) How to use double voltage generators
Push the voltage switch to the right voltage you will use.
WARNING
Make sure to disconnect any load before starting the generators. It is very
dangerous if not.
Air filter cover
11