Alemite 586 Serie Guía De Servicio página 8

SER 586-A (Original Instructions)
CAUTION
Do not expose the Charger to rain, snow, or frost.
Make sure the cord is located so that it will not be
stepped on, tripped over, or otherwise subjected to
damage or stress.
Do not operate the Charger with damaged cord or
plug. Replace immediately.
Do not operate the Charger if it has received a
sharp blow, been dropped, or otherwise damaged
in any way.
Do not disassemble the Charger.
The Charger is designed to operate on standard
household electrical power. Do not attempt to use
it on any other voltage.
Consecutive charging may cause overheating. If
you need to recharge the Battery consecutively,
wait for 15 minutes to allow the Charger to cool.
Do not insert foreign material into the slot for the
Battery in the Charger stand.
Do not disassemble the Battery.
Do not store the gun and Battery assembly in
locations where the temperature may reach or
exceed 104°F (40°C).
Do not short-circuit the Battery.
Do not place the Charger in an area of extreme
heat or cold. It works best at normal room
temperature.
EC DECLARATION OF CONFORMITY
ALEMITE, LLC
167 Roweland Drive,
Johnson City, Tennessee, USA, 37601
Declares that under the sole responsibility for supply of the machin-
ery described as:
TYPE/SERIES: Cordless Grease Gun
MODEL: 586-A, 586-B, 586-C, 586-D
These products are in compliance with the following European Com-
munity Directives:
2011/65/EC, 2006/42/EC, 2014/30/EU
The following standards were used to verify compliance with the
directives:
EN55014-1, EN55014-2, EN50581, EN60745
Approved by:
Robert Hoefler
Director of Engineering/Product Development
671087
Battery Charger Operation
mobile charger 343289. Make sure power circuit voltage is same as
that shown on the charger specifications plate. Ensure the Battery
properly engages with the charger's contacts.
Function of Red and Green Lights
time.
charging. This is normal and does not indicate a problem.
Leaving the Battery in the Charger
LED glowing indefinitely. The Charger will keep the Battery fresh
and fully charged. The Charger features an automatic tune-up mode
which equals or balances the individual cells within the Battery to
enable it to function at peak capacity. Batteries should be tuned-up
weekly or whenever the Battery no longer delivers the same amount
of work. To use the automatic tune-up mode, place the Battery in the
Charger for a minimum of 8 hours.
EC DECLARATION OF CONFORMITY
Declares that under the sole responsibility for supply of the machin-
ery described as:
TYPE/SERIES: Battery charger.
MODEL: 343501
This product in compliance with the following European Community
directives:
Low Voltage Directive 2014/32/EU;
Machinery Directive 2006/42/EC
Electromagnetic Comparability Directive 2014/30/EU. The follow-
ing standard were used to verify compliance with the directives: IEC
60335-1:2010, IEC60335-2-29:2002+A1:2004+A2:2009,
EN 60335-1:2012, EN 60335-2-29:2004+A2:2010, AS/NZS 60335-
1:2011+A12:2012, AS/NZS 60335.2.29:2004+A1:2004+A2:2010
EN 62233:2008, EN 55014-1:2006+A1:2009+A2:2011,
EN 55014-2:1997+A1:2001+A2:2008,
EN 61000-3-2:2006+A1:2009+A2:2009, EN 61000-3-3:2008
Date 12/04/2015
Approved by:
Robert Hoefler - Director of Engineering/Product Development
8
Charge the Battery only with the Charger provided or optional
When the charger is powered on, the Green light will flash one
Green Light Flashing
Charging.
Green Light On
Battery is fully charged.
Red Light Flashing at 4HZ
Bad Battery condition. The Charger has the ability to
detect a weak or damaged battery. If this LED function
occurs, do not continue to charge the Battery. Return it to a
service center or a collection site for recycling.
Red Light Flashing at 1HZ/5HZ
Hot/Cold Battery. When the Charger detects that a Battery
is excessively hot or cold, charging is suspended until the
Battery has normalized. Once battery is at a temperature
between to 40° F (4° C) and 104° F (40° C), the charger
automatically switches to Charging mode. Battery
overheating could be attributed to:
A. Long continuous running
B. Hot ambient temperature
C. One or more cells are damaged
The Battery will become slightly warm to the touch while
The Battery can be left connected in the Charger with the green
ALEMITE, LLC
167 Roweland Drive,
Johnson City, Tennessee, USA, 37601
Cordless Grease Gun
Date 12/04/2015
Alemite LLC