Publicidad
EN
SAFETY INSTRUCTIONS
KEEP THIS USER MANUAL
This manual will be necessary for the safety information and
precautions, installation, use and maintenance instructions.
Keep this manual in a safe place so that can refer you
more later.
NOTE
Caveats, advice and instructions contained in this manual
cannot cover all of the conditions and situations that may
occur.
Common sense and caution cannot be integrated into the
product and must be supplied by the user.
CAUTION: use of this equipment requires some
basic precautions to reduce the risk of accidents and
injury.
CHARACTERISTICS OF THE PRODUCT
1. Powerful, practical and portable, it can pull boats.
vehicles bogged down and other heavy objects.
2. Tows up to 1000 kg on a smooth hard surface.
Read all instructions before using the winch
ATTENTION: Please follow these safety instructions for
your personal safety and that of others because the use
of this equipment requires basic precautions to reduce the
risk of accidents and personal injuries or damage to the
equipment.
-The operator must always act in accordance with the
instructions for use;
-The user must lift the load from the ground to the minimum
speed of the winch. Cable (String, strap) must be tight and
should not be slack when the load is lifted from the ground.
-It is forbidden to lift loads greater than the rated capacity
of the hoist;
-Do not attempt to lift loads fixed or blocked;
-Do not apply lateral traction on charges with winches for
lifting and descent of suspended loads;
-Any excessive idle (for example, engine powered by brief
pulses) should be avoided;
-Do not transport people.
All maintenance and repair work required for the operation
of the winch must be described, for example:
-Lubrication of cables, chains, gear boxes, bearings,
brackets, etc.
-Inspection of the wear parts, such as cables, chains, hooks,
straps and brake pads. Specification of intervals of test and
inspection, as well as criteria of removal;
-Principle of operation of the devices of protection and
regulations in case of outbreak of these devices, for
example when a new setting of the emergency stop device;
-Information related to the verification of the correct
operation of the limiters must be given;
-Measures to avoid possible damage to the winch, in case
of incorrect phase sequence, must be indicated in the
information to use.
ATTENTION
RISK OF INJURY FROM MOVING PARTS
Non respect of these instructions can result in severe injury
or death.
To avoid injury to hands and fingers, do not approach of
cable, the loop, hook and cable guide during installation use.
winching or unwinding.
Always be extremely careful in the handling of the hook and
cable during winching.
-18-
182014-Manual-C.indd 18
182014-Manual-C.indd 18
Always use the hook strap provided whenever you roll or
unroll the cable during the installation or winching to avoid
injury to hands and fingers.
ATTENTION
CHEMICAL RISKS AND FIRE
Non respect of these instructions can result in severe injury
or death.
Remove all you jewelry, go back and tie your hair long and
possibly cover them with a Cap. Wear eye protection.
Don't never lean on the battery to connect the cables.
Ensure that the area to drill for mounting is not on the fuel,
brakes, electrical system, etc.
Do not pass the electric cables:
-over sharp edges
-through or near moving parts
-close to parts that can heat
Isolate and protect all cables and electrical connectors.
Always perform the electric connections as indicated in
the manual.
ATTENTION
RISK OF FALL AND CRASH
Non respect of these instructions can result in severe injury
or death.
Never use as a hoist or to suspend a load.
Never use it to move up, or move a person.
ATTENTION
RISK OF INJURY FROM MOVING PARTS
Non compliance with these instructions may cause minor
injuries to moderate.
General precautions:
First know your winch: take time to read and understand
this manual installation and use, and the basic techniques
of winching guide to familiarize yourself with your winch
and the winching operation.
Do not use this winch if you are under 16 years old.
Never use this winch if you are underwater ' influence of
drugs, alcohol or medication.
Never exceed the capacity of the winch and cable. Double
cable by using a pulley to cover opening to reduce the load.
Facility security:
Always choose a mounting location that is strong enough
to support the capacity of your winch's maximum traction.
Always use the switches, remote controls, accessories and
components facility approved by the manufacturer.
Always use the hardware level 5 minimum, never welded
bolts, or longer than the original bolts.
Always finish the Assembly of the winch and I' attachment
of the hook to the loop of hook before connecting the hoist
for installation.
Always place the cable guide with the WARNING label
above.
Always wrap the cable on the drum as shown on the label
of the drum on the winch.
Required for the proper functioning of the automatic brake
(if winch is so equipped) and the correct orientation of
installation: always extend the cable before use and rewind
in charge before using it.
A taut cable avoids the risk of jam and damage the cable
during the unwinding.
The safety of the winch:
Always inspect the winch and the condition of the cable
before use. A frayed, twisted, or damaged cable must be
replaced immediately. If the winch is damaged or if the
game, it is necessary to fix it immediately.
EN
02/11/2022 12:23
02/11/2022 12:23
Publicidad
