Care And Cleaning; Machine Care; Draining The Machine; Machine Cleaning - Gaymar Medi-ThermTM II Manual Del Operario

Care & Cleaning

10.0 Care and Cleaning

As with any precision equipment, proper care and
maintenance will insure proper performance and
reliability. The following routine maintenance procedures
will help insure dependable Medi-Therm II operation.

10.1 Machine Care

CAUTION
!
• Fill with distilled water only.
Failure to use distilled water may result in
poor machine performance.
• Do not use alcohol. Alcohol may accelerate
blanket deterioration. Alcohol is flammable.
• Do not operate without water, since damage to
internal components may result.
• Do not overfill. Overfilling may result in
overflow because the water in the blanket drains
back into the machine when the machine is
turned off.
• When filling an empty Medi-Therm II machine,
add a small amount of germicidal or sanitizer
solution to the water (Air-Kem A-33 liquid or
equivalent). Carefully follow the manufacturer's
recommended concentration to prevent algae
growth within the Medi-Therm II system and
Hyper/Hypothermia blanket.
Do not use too much concentrate, since it will
result in "foaming," which can reduce the blanket
efficiency and may damage the circulating pump.
• Do not use bleach. Bleach will damage the
heating element.

10.2 Draining the Machine

It is not necessary to drain the Medi-Therm II
machine after each use. However, periodic draining is
recommended at least once a month.
14

10.3 Machine Cleaning

CAUTION
!
Users should not use cleaning or decontamination
methods different from those recommended.
To clean the external surfaces of the machine and
connector hose, use a nonabrasive cleaning solution
(such as warm, soapy water) and a clean cloth.
Wipe or air dry. Apply a disinfectant such as 10%
chlorinated bleach solution (chlorinated bleach with
5.25% sodium hypochlorite) to the external surfaces
and allow to dry.
10.4 Blanket Care
CAUTION
!
• Do not store filled blankets. Algae growth may
occur inside.
• Do not use a blanket if severe algae buildup occurs.
• Do not expose blankets to temperatures over
65°C.
Disposable Blankets
1. After the machine has been turned off, raise the
blanket higher than the machine to allow most of
the water to drain back into the machine.
2. Close both sets of hose clamps.
3. Disconnect the blanket from the machine.
4. Dispose of blanket.
Reusable Blankets
1. After the machine has been turned off, raise the
blanket higher than the machine to allow most of
the water to drain back into the machine.
2. Close both sets of hose clamps.
3. Disconnect the blanket from the machine.
4. Manually clean both sides of the blanket on a
flat surface with warm water, a mild commercial
detergent, and a sponge or cloth.
5. Thoroughly rinse with clean water for 30 seconds.
Medi-Therm
TM
II