Operating Specifications; Special Notices - GE 23 Manual De Utilización Y De Instalación

Performance Data Sheet
SmartWater Filtration System
MWF Cartridge
This system has been tested according to NSF/ANS142/53for reduction of the substances listedbelow.
The concentrationof the indicatedsubstances in water enteringthe system was reduced to a concentration
less than or equal to the permissible limit for water leaving the system, as specified in NSF/ANS142_3o*
'100%safety factors built in for unmetered usage)
Parameter USEPA ]nfluent
MCL Challenge Concentration
(]florin( -- 2.0 rag/L_+ ]0%
T&O
-- --
Pani(ulate** -- _>10,000 parti(les/ml,
Standard No. 42: Aesthetic EffeOs
lnfluent Effluent
Average Average Maximmn
].96 rag/l,
0.06 Ing/l,
0.] ] rag/l,
(i,400,000 #/mE 58,833 #/mL 150,000 #/ml,
Standard No. 53: Health Effects
Parameter
USEPA
MCL
0.5 NT[
_> 99.95!_ Rc(/ucthm
_> 9!1% Rcd/tction
0.015 rag/l,
0.015 mg/L
0.002 mg/L
0.002 mg/L
0.002 mg/L
0.0002 rag/I,
0.070 mg/L
0.003 mg/L
0.005 mg/L
0.040 mg/L
0.075 mg/L
0.(X)3 mg/L
"IinSidiw
(Xsts
_sl)estos
[ _ea(/at pH 6.5
][_ea(/at pH 8.5
M_r/ur} at pl 16.5
M_r/ur} at pl i 8.5
Nachlor
1.indane
2,€1)
"Ibxaph_ nc
Benz( n(
Cafl)ofilran
1,4dich/0mbenzene
Atrazin_
/xffluent hffluent
Challenge Concentration Average
11 ± 1 NT( '*** 10.5 NI'('
.Minilnm_ 50,(}00 l, 1] 8,750 #/l,
] (F to 10'sfibers/l _; > ]()pro 57 MF/I,
0.15 mg/L ± 1()5?i 0.1 ,',67 rag/l,
0.] 5 mg/][, ± ]()!_i 0.] 433 mg/l,
0.006 mg/L ± ] 0!i 0.0059 mg/I,
0.006 mg/L ± ] 0!1 0.0057 mg/I,
0.04 mg/L ± 10% 0.03(i7 mg/I,
0.002 mg/L + 10!_ 0.0020 rag/I,
0.210 mg/L + 10!_ 02033 rag/I,
0.015 rag/i,± 10% 0.0160 rag/I, 0.00100 rag/I,
0.015 rag/L± 10!_ 0.0145 rag/I, (}.(}0050(}mg/L
(}.(180mg/L ± 10!_ 0.0830 rag/I, (}.(}0100(}mg/L
0.225 rag/L± 10!_ 02283 rag/I, 0.(}00500 mg/L
0.(}09 mg/L ± 10!_ 0.0087 rag/I, < 0.(}005 mg/L
Effluent
Average Maxlmtml
0.14 NI'( ' 0.28 NTL
< 1 #/I, 4 #/I,
0.996 MF/I, < 1 MF/I,
< 0.00] */N/I, < 0.001 rag/l,
< 0.001 mg/L < 0.001 mg/l,
0.000350 mg/L 0.0007 mg/L
0.000325 mg/L 0.000(i mg/L
0.00023 mg/L 0.0004 mg/L
< 0.00(X)2 rag/q, < 0.(}0002 mg/L
0.00337 mg/L 0.011000 rag/I,
0.001000 rag/I,
0.000500 rag/I,
0.001000 rag/I,
0.000500 rag/I,
< 0.0005 mg/L
% Reduction
Average Minimum
96.77% !14.74%
9!).14% !17.97%
Min. Required
Reduction
> 5(1%
>_85!_i
% Reduction
Average Minimum
98.54% 97.20%
> 9!).!19% > 9!).!19%
99.60% 99.39!_i
99.36% 9!).29%
99.30% 9!).29%
94.70% 87.5()!_i
93.20% 89.29%
99.34% 98.67%
99.0t1% 98.95%
98.32% 94.50%
93.44% 91.67%
96.51% 95.83%
98.78% 98.65%
9{).78% 99.77%
94.22% 93.33%
Min. Required
Reduction
0.5 NT( '
_> 99.95%
_>99%
0.010 rag/I,
0.0] 0 mg/L
0.002 mg/L
0.002 mg/L
0.002 mg/L
0.0002 mg/L
0.070 mg/L
0.003 mg/L
0.005 mg/L
(}.04 rag/I,
0.075 mg/L
0.003 mg/L
Tested usfl_g a f/ow rate of O.5O gpm; pressure of 6Opsig pH of 7,5_+0,5; temp, of 68°_+ 5°F(20°_+3°C1
_ Measurement in Partic/es/m/, Partic/es used were 0,5-1 microns
.... NTU=Nephe/ometric Turbidity units
Operating Specifications
[] (:apacit}: certified h)r up to 300 gall(ms ( 11 .,a l) ; up to six months h)r models without a replacement filter indicator light;
up to one _ear fi)r models _dth a replacement filter indicator light
[] Pressure requirement: 40-12(/psi (2.8-8.2 bar), non-shock
[] Temperature: 33-100°F (0.6-38"(:)
[] FII)_ rate: 0.5 gpm (1.9 lpm)
General Installation/Operation/Maintenance Requirements
[] Hush new c'_rtrid-e at hdl flo,a h)r 3 minutes to I ,
, _ )urge out trapped air.
[] Replace c'u'tridoe, _ raven the indicator light flashes or ",,4_ter flow rate is reduced on non-indicator units.
Special Notices
[] Installation instructions, parts and serG(e a_ailabilit), and standard warrant} are included with the product when shipped.
[] This drinldng water s}stem I/it/st be maintained according to Illanttfitcttll'el"S illStl fictions, including replacement of filter cartridges.
[] Do not use _ith _ater that is
microbi(dogicall}
tmsafe or of
unknown
quality _ithout adequate disinfection before or
after the sxstem. Sxstems certified for cxst reducti(m max be used on disinfected water that me} contain filterable cxsts.
[] The contaminants or other substances remoxed or redtlced b_ this water treatment s}stem are not necessarilx in )our water.
[] Check for compliance with the state and local laws and regulations.
[] Note that
while the
testing was perfl)rmed under standard laboratorx, clmditions, actual performance me} vat}. S}stems must
be installed
and
operated in accordance vJth mantdhcturer's recommended procedm'es
and guidelines.
Stmldard No. 42: Aeslhetic Effects
Chemical Lnit
Chlorine Taste m_d Odor
Methmfital Filtration Lnit
Parti(ulat( Reduction, Class I
System "[-(,st(d and Certified by NSF International against ANSI!NSF Standard 42 & 53 for tile reduction of:
Standard No. 53: Health Effects
Chemical Reduction Unit
LMachlor and Atrazine Re(hlction
Benzene and Carbofuran Reduction
1,4 dichlor(lbenzene and 2,44) Reduction
Lead and IAn(lane Reduction
Mercmy and Toxaphene Reduction
Mechanical Fihration [nit
Turl)iditv Reduction
Cyst all({ Asbestos Re(luction
Malmthctured tot: General Electric Colnpal_y, Louisville, KY 40225
EPA EST No. 070595-MN-001
38