Changing The FI Lter; Service - BOXER Drester Double Aqua DB22A Manual De Operación

3. FILTRATION
Open the drain-valve (item 10 illustration 2) and drain the wash-basin
completely into the fi lter (item 11 illustration 2). Clean the inside of
the wash-basin thoroughly with the cleaning brush (i.e. with recycled
water), so that any remains of residual fl ocks are completely drained
into the fi lter.
When this is done, close the drain-valve
CHANGING THE FILTER
N.B.: MAKE SURE THAT YOU USE ORIGINAL DRESTER FILTERS,
NR. 8701 (FINE FILTER), AND NR. 8702 (PRIMARY FILTER).
THESE FILTERS HAVE BEEN TESTED AND APPROVED BY THE
PAINT MANUFACTURERS.
The primary fi lter (item 2 illustration 11) collects most of the
coagulated sludge, while the fi ne fi lter (item 1 illustration 11)
collects the fi ner paint particles.
Remove the sludge from the primary fi lter after each coagula-
tion process (once it is completely dry, the sludge is easy to
remove from the fi lter). By doing so the primary fi lter can be
re-used up to 10 times.
The fi ne fi lter will gradually become blocked after trapping the
fi ner paint particles. In general, the fi ne fi lter can be used for
up to 5 coagulation processes. The fi ne fi lter must however be
changed every 1-2 months, otherwise there is a risk that mould
will develop.
N.B.: THE COAGULATION SLUDGE MUST BE HANDLED IN
ACCORDANCE WITH REGULATIONS FROM THE APPROPRIATE
AUTHORITY. INFORMATION FROM THE PAINT SUPPLIER MAY
BE NECESSARY.
6

SERVICE

Weekly
– Remove the strainers at the bottom of the automatic
washers (item 2 illustration 5) and clean them.
Do not forget to re-fi t !
Monthly
– Remove the fi ve nozzles in each automatic washer and
clean them with clean solvent. (see illustration 8).
When changing drums
– Check and if necessary clean the strainers on the suction
hoses.
When changing fi lters
– Check and if necessary clean the strainer on the suction
pipe (item 15 illustration 2).
– Take out the fi ltrate container (item 7 illustration 2) and
empty it completely. Rinse it with water and wipe it off with
cloth or paper.
Every month
– Change the water completely.
16011 rev 2012-02-29