General Instructions - Akron STYLE 3578 STREAMMASTER Instrucciones De Instalación, Funcionamiento Y Mantenimiento

....WARNING:. When.the.cover.of.the.control.box.or.logic.box.is.removed,.check.that.the.O-ring.under.the.cover.is..
. . intact.and.free.of.dirt.and.debris .
....WARNING:. The.StreamMaster.monitor.uses.current.limiting.for.both.the.monitor.and.nozzle . . .Use.only.appropriate..
. . Akron.Brass.Company.nozzles .
....WARNING:. Do.not.use.the.electric.controls.when.the.override.cranks.are.being.used.or.are.in.position.for.use .
....WARNING:. Make.the.connection.of.the.vehicle.and.auxiliary.battery.the.final.step .
....WARNING:. Replace.the.identification.tags.if.they.should.become.worn.or.damaged .
....WARNING:. DO.NOT.exceed.the.maximum.pressure.or.flow.ratings.of.the.monitor . . .Exceeding.these.ratings.may.lead.. .
. . to.an.injury.or.may.cause.damage.to.the.monitor .
....WARNING:. DO.NOT.install.shutoffs.on.the.outlet.of.the.monitor . . Shutoffs.increase.the.potential.for.pressure.surges.. .
. . due.to.water.hammer,.which.have.the.potential.to.cause.an.injury.or.damage.to.the.monitor .
....WARNING:. The.StreamMaster.monitor,.nozzle,.logic.box,.control.box,.tether.controller,.and.field.adjustable.stops.are.. .
. . made.for.optimal.performance . . .Do.not.alter.in.any.manner .
....WARNING:. The.StreamMaster.monitor.was.designed.for.use.with.the.Akromatic.nozzle . . .Use.of.any.other.nozzle..
. . could.affect.the.speed.or.operation.of.the.unit.and.should.be.tested.before.being.put.into.service .
....WARNING:. The.StreamMaster.monitor.contains.moving.parts . . Keep.hand,.finger.and.objects.away.from.pinch...
. points.(Figure.1) . .
....WARNING:. Disconnect.power.and.disable.flow.before.maintenance .
....WARNING:. Keep.all.personnel.out.of.the.Danger.Zone.(Figure.2),.in.front.of.the.outlet.of.the.monitor.
. . when.the.water.. source.is.attached . . Dangerous.flow.velocities.can.cause.serious.injury .
....WARNING:. Not.designed.for.explosive.environments .

GENERAL INSTRUCTIONS

•.. R eview.the.instructions,.wiring.diagram,.component.layout.and.rotational.stops.diagram.before.installing.this.unit . . .
This.unit.operates.on.12.volt.DC.or.24.volt.DC.depending.on.the.unit.chosen . . All.electrical.current.flows.through..
the.wires . . The.monitor.does.not.act.as.a.ground . . The.wires.from.the.control.boxes.can.be.cut.to.the.length.for.the..
application.plus.10.inches.(See.STEP.2) . . .Do.not.extend.the.wires.from.the.logic.box.to.the.monitor .
•.. T he.optional.auxiliary.battery.is.used.for.power.failures.and.to.ensure.that.the.proper.voltage.and.current.are..
maintained.at.the.logic.box.when.using.a.smaller.gauge.wire.(12.Awg).for.the.power.leads.(vehicle.battery) . . .
If.the.optional.auxiliary.battery.is.used,.do.not.extend.the.auxiliary.battery.wires . . This.will.ensure.that.the..
proper.voltage.and.current.are.maintained.at.the.monitor.for.it.to.operate.properly . . The.optional.battery.is..
automatically.recharged.by.the.truck.electrical.system.through.the.positive.(auxiliary.battery).and.ground..
connections.on.the.circuit.board.(Figure.6) . . The.vehicle.battery.connections.must.have.power.turned.on..
whenever.the.truck.is.running.so.that.the.battery.can.be.recharged.properly . . If.possible,.connect.the.positive..
(vehicle.battery).wire.directly.to.the.main.vehicle.battery.or.main.master.switch . . A.diode.in.the.logic.box.will..
prevent.the.optional.auxiliary.battery.from.feeding.current.back.into.the.main.truck.system .
•.Not.recommended.for.use.in.salt.water.applications .
•.For.firefighting.by.trained.firefighters.only .
•.For.use.with.water.or.standard.fire.fighting.foams.only . . After.use.with.foam,.flush.with.fresh.water .
•.Do.not.use.the.StreamMaster.nozzle.as.a.forcible.entry.tool . .
•.Drain.the.StreamMaster.monitor.and.nozzle.after.use.to.prevent."freeze.damage" .
•.. E nsure.that.the.thread.in.the.nozzle.swivel.matches.the.thread.on.the.StreamMaster.outlet . . Do.not.overtighten..
the.nozzle.onto.the.StreamMaster .
Page.2
. .
. .
.
.
.
. .
. .