Troubleshooting Guide - Omega 55101 Instrucciones De Funcionamiento Y Manual De Piezas

TROUBLESHOOTING GUIDE

The following information is intended as an aid in determining if problem exists. Pumps should be repaired only by authorized
Omega Service Center. For repair service, contact service center in your area.
Symptom
Erratic application action
Application does not extend,
move or respond to pressurized
fluid
Application responds to
pressurized fluid, but system does
not maintain
pressure
Application responds slower than
normal
Application does not return fluid to
pump (i.e. cylinder will not retract)
Poor performance
For a period of one (1) year from date of purchase, SFA Companies will repair or replace, at its option,
without charge, any of its products which fails due to a defect in material or workmanship under normal usage. This
limited warranty is a consumer's exclusive remedy.
Performance of any obligation under this warranty may be obtained by returning the warranted product,
freight prepaid, to SFA Companies Warranty Service Department, 10939 N. Pomona Ave., Kansas City, MO 64153.
Except where such limitations and exclusions are specifically prohibited by applicable law, (1) THE
CONSUMER'S SOLE AND EXCLUSIVE REMEDY SHALL BE THE REPAIR OR REPLACEMENT OF DEFECTIVE
PRODUCTS AS DESCRIBED ABOVE. (2) SFA Companies SHALL NOT BE LIABLE FOR ANY CONSEQUENTIAL
OR INCIDENTAL DAMAGE OR LOSS WHATSOEVER. (3) ANY IMPLIED WARRANTIES, INCLUDING WITHOUT
LIMITATION THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR
PURPOSE, SHALL BE LIMITED TO ONE YEAR, OTHERWISE THE REPAIR, REPLACEMENT OR REFUND AS
PROVIDED UNDER THIS EXPRESS LIMITED WARRANTY IS THE EXCLUSIVE REMEDY OF THE CONSUMER,
AND IS PROVIDED IN LIEU OF ALL OTHER WARRANTIES, EXPRESS OR IMPLIED. (4) ANY MODIFICATION,
ALTERATION, ABUSE, UNAUTHORIZED SERVICE OR ORNAMENTAL DESIGN VOIDS THIS WARRANTY AND
IS NOT COVERED BY THIS WARRANTY.
Some states do not allow limitations on how long an implied warranty lasts, so the above limitation may not
apply to you. Some states do not allow the exclusion or limitation of incidental or consequential damages, so the
above limitation or exclusion may not apply to you. This warranty gives you specific legal rights, and you may also
have other rights, which vary from state to state.
Possible Causes
• Air in the system.
• External leak.
• Internal hydraulic leak.
• Overload condition.
• Release valve not closed.
• Loose couplers/connections.
• Faulty couplers/connections.
• Pump malfunction.
• Overload condition.
• Release valve not closed.
• Pump or valve malfunction.
• Application/connection leaking.
• Loose connection or coupler.
• Restricted hydraulic line or fitting.
• Application/connection leaking.
• Malfunctioning coupler, damaged
application.
• Reservoir overfilled
• Fluid level in pump is low.
ONE YEAR LIMITED WARRANTY
• Follow Bleeding/Venting Instructions, Pg. 4.
• Tighten all connections.
• Contact service center.
• Remedy overload condition.
• Ensure release valve closed.
• Tighten couplers/connections.
• Replace couplers/connections.
• Contact service center.
• Remedy overload condition.
• Ensure release valve closed.
• Contact Service Center.
• Replace application/connection.
• Tighten connection or coupler.
• Clean and replace if damaged.
• Replace application/connection.
• Secure load by other means. Open release
valve, depressurize pump and hose, remove
coupler and/or application, then renew or
replace.
• Secure load by other means. Open release
valve, depressurize pump and hose, remove
application, then drain fluid to proper level.
• Ensure proper fluid level.
10939 N. Pomona Ave. Kansas City, MO 64153
6
Corrective Action
SFA Companies
888-332-6419
sales@omegalift.com