Tabla De Contenido; Limited Warranty - Grundfos UP 200 Serie Instrucciones De Instalacion Y Operacion

English (US) Installation and operating instructions
Original installation and operating
instructions
CONTENTS
1. Limited warranty
2. Introduction
2.1 Safety warning
2.2 Electrical work
3. Pre-installation checklist
3.1 Confirm you have the correct pump
3.2 Check the condition of the pump
3.3 Verify electrical requirements
3.4 Location
3.5 Pumped liquid requirements
4. Installation procedures
4.1 Electrical preparation
4.2 Piping considerations
4.3 Connect the pump
4.4 Electrical connection
5. Starting the pump
5.1 Vent the piping system
5.2 Voltage selection
6. Troubleshooting
6.1 Fault finding chart
6.2 Preliminary checks
6.3 Current measurement
6.4 Insulation resistance (lead-to-ground) 12
6.5 Winding resistance (line-to-line)
6.6 Winding resistance chart
7. Replacing components
7.1 Removing the pump head
7.2 Fitting the pump head
7.3 Replacing the terminal box or
capacitor
8. Disposal
WARNING
Prior to installation, read these
installation and operating instructions.
Installation and operation must
comply with local regulations and
accepted codes of good practice.
This booklet should be left with the
owner of the pump for future
reference and information regarding
its operation.
4

1. Limited warranty

Products manufactured by GRUNDFOS PUMPS
CORPORATION (Grundfos) are warranted to
the original user only to be free of defects in
Page material and workmanship for a period of
24 months from date of installation, but not more
4
than 30 months from date of manufacture.
5
Grundfos' liability under this warranty shall be
limited to repairing or replacing at Grundfos'
5
option, without charge, F.O.B. Grundfos' factory
5
or authorized service station, any product of
5
Grundfos' manufacture. Grundfos will not be
5
liable for any costs of removal, installation,
5
transportation, or any other charges which may
arise in connection with a warranty claim.
5
Products which are sold but not manufactured
5
by Grundfos are subject to the warranty
6
provided by the manufacturer of said products
6
and not by Grundfos' warranty. Grundfos will not
6
be liable for damage or wear to products caused
by abnormal operating conditions, accident,
7
abuse, misuse, unauthorized alteration or repair,
7
or if the product was not installed in accordance
8
with Grundfos' printed installation and operating
9
instructions.
9
To obtain service under this warranty, the
9
defective product must be returned to the
distributor or dealer of Grundfos' products from
10
which it was purchased together with proof of
10
purchase and installation date, failure date, and
11
supporting installation data. Unless otherwise
11
provided, the distributor or dealer will contact
Grundfos or an authorized service station for
12
instructions. Any defective product to be
returned to Grundfos or a service station must
13
be sent freight prepaid; documentation
14
supporting the warranty claim and/or a Return
14
Material Authorization must be included if so
14
instructed.
GRUNDFOS WILL NOT BE LIABLE FOR ANY
15
INCIDENTAL OR CONSEQUENTIAL
15 DAMAGES, LOSSES, OR EXPENSES ARISING
FROM INSTALLATION, USE, OR ANY OTHER
CAUSES. THERE ARE NO EXPRESS OR
IMPLIED WARRANTIES, INCLUDING
MERCHANTABILITY OR FITNESS FOR A
PARTICULAR PURPOSE, WHICH EXTEND
BEYOND THOSE WARRANTIES DESCRIBED
OR REFERRED TO ABOVE.
Some jurisdictions do not allow the exclusion or
limitation of incidental or consequential
damages and some jurisdictions do not allow
limit actions on how long implied warranties may
last. Therefore, the above limitations or
exclusions may not apply to you. This warranty
gives you specific legal rights and you may also
have other rights which vary from jurisdiction to
jurisdiction.