Safety Checks - Pre-Starting; Inspection Prior To Operation - Ingersoll Rand DX-500E Manual De Utilización Y Mantenimiento

SAFETY CHECKS – PRE-STARTING
READ this Instruction Manual and the Engine Manual.
IF YOU ARE IN DOUBT OF THE OPERATION OF THIS UNIT
AFTER READING THESE PROCEDURES – SEE YOUR
SUPERVISOR. READ ALL OF THE INSTRUCTIONS PRIOR
TO STARTING THE MACHINE.
Before starting each day, in addition to the 10 hour daily routine
maintenance, check or inspect the following items to ensure
trouble free performance.
1. Check fluid lines, hoses, fittings, filler openings, drain plugs,
pressure cap, muffler, safety shrouds, retighten bolts and
nuts and the area underneath the unit for signs of leakage or
damage. Fix any leaks and correct any damage before
operating. Do not operate faulty equipment.
2. Inspect the entire unit for damaged or missing parts and
repair or replace them as needed.
3. Check the fuel level. If necessary, fill the fuel tank with the
proper fuel.
4. Check engine Oil level.
5. If you are going to compact hot asphalt or if you want extra
weight on the rollers, fill in the water tank. Only use clear
water. If necessary, add anti-freeze to the water.

INSPECTION PRIOR TO OPERATION

Parking on slope
Avoid parking on a slope as much as possible.
However, if parking on a slope is unavoidable, shift the parking
brake lever to "LOCK" position.
Be sure to release the parking brake before forward/reverse
operation.
Filling fuel tank
Remove the FUEL TANK CAP ( , [Figure 1]) and fill with light
diesel fuel per engine manual.
Figure 1
Fuel is flammable. It may cause injury and property
damage.
Shut down the engine, extinguish all open flames and do
not smoke while filling the fuel tank.
Always wipe up any spilled fuel.
Coolant
To fill the radiator with coolant remove RADIATOR CAP
( , [Figure 1]) and fill radiator. Secure the pressure cap after
filling.
Do not pour muddy water or seawater into radiator.
In cold weather tap water in the radiator may freeze and
damage the radiator. To prevent this, add anti-freeze to the
coolant.
Follow coolant manufacturer's recommendation for mixing ratio.
When not using an anti-freeze, and there is a chance of
freezing, be sure to drain radiator of coolant after each use.
Capacity of coolant: 1.2 liters.
Do not remove the radiator cap while engine is running or
when hot.
DX-500E/DX-700E Walk Behind Duplex Rollers
6-EN
WARNING
CAUTION
Operation & Maintenance Manual