Publicidad
Figure #24
Figure #25
Page
-60-
MAINTENANCE
These Maintenance Procedures Must Be Done Every
Week:
WARNING:
WARNING: Always wear eye protection and pro-
CAUTION: To prevent damage to the machine,
NOTE: Always turn off key switch before servicing the
machine.
WARNING: Always wear eye protection and
1. To inspect batteries, tip up recovery tank until it locks
in up position. See Figure #24.
2. Disconnect the batteries. Use a cloth and a solution
of ammonia or bicarbonate of soda to wipe the top of the
batteries. Clean the battery terminals. Reconnect the
batteries.
3. Check the hoses for leaks, obstructions and other
damages.
4. Check and clean the filter screen in the solution hose.
To clean the screen, follow this procedure:
a. Turn the connector to the left.
b. Remove and clean the filter screen.
c. Install the filter screen in the hose. Turn the
5. Use a grease gun to lubricate the drive wheel and the
casters. See figure #25.
6. Check tire pressure. Tire pressure should be about 50
psi.
®
American-Lincoln
Operator's Manual - Encore
Maintenance and repairs must be
done by authorized personnel only.
Always empty the solution tank and
the recovery tank before doing any
maintenance.
tight.
tective clothing when working near
batteries. Do not put tools or other
metal objects across the battery ter-
minals or the tops of the batteries.
and discharge across the tops of the
batteries, do not fill the batteries
above the bottom of the tube in each
cell. Wipe any acid from the ma-
chine or the tops of the batteries. Do
not add acid to battery after installa-
tion.
protective clothing when working
near batteries. NO SMOKING!
connector to the right to connect the hose.
2
S28/D28/S33/D33/S38/D38 WB
EN
Keep all fasteners
Publicidad
