Tabla de contenido
Publicidad
Enlaces rápidos
OWNER / OPERATOR MANUAL
MODE D'EMPLOI
MANUAL DE INSTRUCCIONES
WARNING
The engine exhaust from
this product contains
chemicals known to the
State of California to cause
cancer, birth defects or
other reproductive harm.
WARNING
Before using our
brushcutters, please read
this manual carefully to
understand the proper use
of your unit.
APPLICABLE SERIAL NUMBERS :
DRIVE UNIT 40400101 and up
ENGINE UNIT KU40001 and up
AVERTISSEMENT
Les échappements du
moteur de ce produit
contiennent des produits
chimiques connus par l'Etat
de Californie comme étant
responsables de cancers,
d'anomalies congénitales et
d'autres atteintes à
l'appareil reproducteur.
AVERTISSEMENT
Avant d'utiliser cette
débroussailleuse, veuillez
lire attentivement ce manuel
afin de bien comprendre le
bon fonctionnement de cet
appareil.
NUMEROS DE SERIE APPLICABLES :
BOITE DE COMMANDES 40400101 et au-delà
MOTEUR KU40001 et au-delà
GRASSTRIMMER
TAILLE-BORDURES
CORTACÉSPED
BT250
ADVERTENCIA
Los gases de escape del
motor de este producto
contienen sustancias
químicas conocidas por el
Estado de California como
causantes de cáncer,
malformaciones en recién
nacidos y otros problemas
de reproducción.
ADVERTENCIA
Antes de usar nuestros
productos, lea
detenidamente este manual
a fin de familiarizarse con el
uso correcto de este
aparato.
NÚMEROS DE SERIE APLICABLES:
UNIDAD DE ACCIONAMIENTO 40400101 y superior
UNIDAD DE MOTOR KU40001 y superior
BT25-00001 (706)
Publicidad
Tabla de contenido
Manuales relacionados para Zenoah RedMax BT250
Resumen de contenidos para Zenoah RedMax BT250
- Página 1 BT25-00001 (706) OWNER / OPERATOR MANUAL MODE D’EMPLOI MANUAL DE INSTRUCCIONES GRASSTRIMMER TAILLE-BORDURES CORTACÉSPED BT250 WARNING AVERTISSEMENT ADVERTENCIA Les échappements du Los gases de escape del The engine exhaust from moteur de ce produit motor de este producto this product contains contiennent des produits contienen sustancias chemicals known to the...
-
Página 2: Safety First
English SAFETY FIRST Instructions contained in warnings within this manual marked with a symbol concern critical points which must be taken into consideration to prevent possible serious bodily injury, and for this reason you are requested to read all such instructions carefully and follow them without fail. -
Página 3: Tabla De Contenido
Français Español SECURITE LA SEGURIDAD PRIMERO Les instructions contenues dans les mises en Las instrucciones que aparecen en este manual garde de ce mode d’emploi portant le symbole bajo las advertencias marcadas con el símbolo concernent les points critiques qui doivent être hacen referencia a puntos críticos que deben pris en considération pour éviter les blessures tomarse en consideración para evitar posibles... -
Página 4: Parts Location
Displacement ················································································································· 1.6 cu-in (25.4 cm Max. output····················································································································· 1.2 Hp at 8500 rpm Fuel ·················································································································· Mixture (Gasoline 50 : Oil 1) (when using RedMax/ZENOAH genuine oil) Carburetor ··············································································································· Walbro Diaphragm type Spark plug ····························································································································· NGK BPMR7A Fuel tank capacity··························································································································· 22.3 fl.oz (0.62 ) Transmission ········································································································... -
Página 5: Emplacement Des Composants
Cylindrée ········································································································································· 25,4 cm Puissance maximale ······································································································ 1,2 CV à 8500 t/mn Carburant ····································································································· Mélange (essence 50 : huile 1) (Lors de l’utilisation de la véritable huile RedMax/ZENOAH) Carburateur ··················································································································· Type à Diaphragme Bougie d’allumage ················································································································· NGK BPMR7A Contenance du réservoir de carburant ············································································································· 0,62 Transmission ·············································································... -
Página 6: Emission Control
AND ADJUSTMENTS. USE JASO FC OR ISO EGC GRADE 50:1 OIL. ENGINE FAMILY : 7HCPS.0254AD ; EM DISPLACEMENT : 25.4cc MANUFACTURED : ZENOAH CO.,LTD. *1: The year will be changed every year of manufacturing. *2: The initial number will be changed every year of manufacturing. -
Página 7: Etiquettes D'aVertissement Placées Sur La Machine
Cylindree du moteur : 25.4cc FABRIQUE PAR: Cilindrada del motor : 25.4cc Fabricado por: ZENOAH CO.,LTD. ZENOAH CO.,LTD. *1: L'année changera chaque année de la fabrication. *1: El año cambiará cada año de fabricación. *2: Le nombre initial changera chaque année de la *2: El número inicial cambiará... -
Página 8: For Safe Operation
English 5. For safe operation 1. Read this manual carefully until you completely understand and follow all safety and operating instructions. 2. Keep this manual handy so that you may refer to it later whenever any questions arise. Also note, if you have any questions which cannot be answered herein, contact the dealer from whom you purchased the product. -
Página 9: Consignes De Securite
Français Español 5. Consignes de securite 5. Instrucciones de seguridad 1. Lire ce manuel attentivement jusqu’à une 1. Lea detenidamente este manual hasta compréhension totale et suivre toutes les comprender cabalmente todas las instrucciones instructions de sécurité et d’utilisation. de seguridad y uso. 2. -
Página 10: Before Starting The Engine
English 5. For safe operation other times when weather conditions might make it unsafe to use the product. ■ WORKING PLAN 1. You should never use the product when under the influence of alcohol, when suffering from exhaustion or lack of sleep, when suffering from drowsiness as a result of having taken cold medicine or at any other time when a possibility exists that your judgment might be impaired or that you might not be... - Página 11 Français Español 5. Consignes de securite 5. Instrucciones de seguridad c. Pendant les averses, les orages avec éclairs, par otra circunstancia en que las condiciones grands vents ou toute autre condition climatique climáticas puedan hacer inseguro el uso del rendant l’utilisation de la machine dangereuse. producto.
-
Página 12: Starting The Engine
(idle position). If it continues to rotate even after the throttle has been moved fully back, turn off the engine and take the unit to your authorized RedMax/ZENOAH servicing dealer for repair. ■ USING THE PRODUCT IMPORTANT Cut only materials recommended by the manufacturer. - Página 13 (en revendeur RedMax/ZENOAH agréé afin de le faire ralentí). Si sigue girando incluso después de que el réparer.
- Página 14 3. When replacing the cutting attachment or any other part, or when replacing the oil or any lubricant, always be sure to use only RedMax/ZENOAH products or products which have been certified by RedMax/ZENOAH for use with the RedMax/ ZENOAH product.
-
Página 15: Mantenimiento
4. Pour toute pièce devant être remplacée, opération asegúrese de usar solamente productos d’entretien ou de réparation, contacter le centre de RedMax/ZENOAH o productos que hayan sido SAV agréé par RedMax/ZENOAH le plus proche certificados por RedMax/ZENOAH para ser pour demander assistance. usados con esta máquina. -
Página 16: Handling Fuel
■ HANDLING FUEL 1. The engine of the RedMax/ZENOAH product is designed to run on a mixed fuel which contains highly flammable gasoline. Never store cans of fuel or refill the tank of the unit in any place where there... -
Página 17: Manipulation Du Carburant
■ MANIPULACIÓN DEL COMBUSTIBLE 1. Le moteur de la débroussailleuse RedMax/ZENOAH est conçu pour fonctionner avec du mélange 1. El motor de este producto RedMax/ZENOAH ha sido contenant de l’essence hautement inflammable. Ne diseñado para funcionar con una mezcla de... - Página 18 English 6. Set up ■ INSTALLING HANDLE (SE1) • Mount the handle to the shaft tube and clamp it at your best operating position. ■ INSTALLING DEBRIS GUARD (SE2) • This model pack with already installing debris guard. • Put the debris guard on the shaft tube near the gear box, attach it with the screw, washer and nut provided.
-
Página 19: Assemblage
Français Español 6. Assemblage 6. Montaje ■ INSTALLATION DE LA POIGNEE ■ INSTALACIÓN DEL MANGO • Montez la poignée sur le tube et clavetez-la dans • Monte el mango al tubo del eje y afiáncelo en una une position qui vous sera confortable. posición que sea cómoda para usted. - Página 20 Select outdoor bare ground for fueling and move at least 3m (10ft) away from the fueling point before starting the engine. • The RedMax/ZENOAH engines are lubricated by oil specially formulated for air-cooled 2-cycle gasoline engine use. If RedMax/ZENOAH oil is not available, use an anti-oxidant added quality oil expressly labeled for air-cooled 2-cycle engine use.
-
Página 21: Carburant
• Les moteurs RedMax/ZENOAH sont lubrifiés à l’aide • Los motores de RedMax/ZENOAH están lubricados d’une huile spécialement conçue pour les moteurs 2 con un aceite especialmente formulado para uso en temps à... -
Página 22: Fueling The Unit
English 7. Fuel ■ HOW TO MIX FUEL IMPORTANT Agitate carefully. 1. Measure out the quantities of gasoline and oil to be mixed. 2. Put some of the gasoline into a clean, approved fuel container. 3. Pour in all of the oil and agitate well. 4. -
Página 23: Como Mezclar El Combustible
Français Español 7. Carburant 7. Combustible participer ainsi à la protection de l’environnement et • Gasolinas o aceites de mala calidad puede dañar de votre santé. los anillos de sellado, las líneas o el tanque de • De l’essence ou de l’huile de basse qualité risque combustible del motor. - Página 24 English 7. Fuel cause severe damage to the internal engine parts very quickly. 2. GASOHOL – It can cause deterioration of rubber and/or plastic parts and disruption of engine lubrication. 3. OIL FOR 4-CYCLE ENGINE USE – It can cause spark plug fouling, exhaust port blocking, or piston ring sticking.
- Página 25 Français Español 7. Carburant 7. Combustible 1. ESSENCE SANS HUILE (ESSENCE PURE) – 1. COMBUSTIBLE SIN ACEITE (GASOLINA CRUDA) L’essence pure est capable d’endommager très – Esto ocasionará rápidamente daños graves a las rapidement les pièces du moteur. partes internas del motor. 2.
-
Página 26: Starting Engine
English 8. Operation ■ STARTING ENGINE WARNING The cutting head will start rotating upon the engine starts. 1. Rest the unit on a flat, firm place. Keep the cutting head off the ground and clear of surrounding objects as it will start rotating upon starting of the engine. 2. -
Página 27: Fonctionnement
Français Español 8. Fonctionnement 8. Uso ■ DEMARRAGE DU MOTEUR ■ ARRANQUE DEL MOTOR AVERTISSEMENT ADVERTENCIA La tête de coupe commencera à tourner au El cabezal de corte empezará a girar cuando el démarrage du moteur. motor arranque. 1. Poser la machine dans un endroit plat et ferme. Ne 1. -
Página 28: Stopping Engine
English 8. Operation ■ STOPPING ENGINE 1. Release the throttle lever and run the engine for a half minute. 2. Shift the ignition switch to the STOP position. NOTE • Except for an emergency, avoid stopping the engine while pulling the throttle lever. ■... -
Página 29: Apagado Del Motor
Français Español 8. Fonctionnement 8. Uso ■ ARRET DU MOTEUR ■ APAGADO DEL MOTOR 1. Relâcher le levier d’accélération et laisser tourner le 1. Suelte la palanca del acelerador y arranque el motor moteur pendant encore 30 secondes. durante media minuto. 2. - Página 30 English 8. Operation than placing the full workload on the arm and hands. 6. Take precautions to avoid wire, grass and dead, dry, long-stem weeds from wrapping around the head shaft. Such materials can stall the head and cause the clutch to slip, resulting in damage to the clutch system if repeated frequently.
- Página 31 Français Español 8. Fonctionnement 8. Uso 4. Ne jamais pivoter trop rapidement en utilisant la punto de perder el equilibrio o el control de la machine au risque de perdre l’équilibre ou le misma. contrôle de la machine. 5. Intente controlar el movimiento de corte con la 5.
-
Página 32: Maintenance Chart
English 9. Maintenance Maintenance, replacement, or repair of the emission control device and systems may be performed by any non-road engine repair establishment or individual. ■ MAINTENANCE CHART every every every system/compornent procedure before hours hours hours note after after after ✔... -
Página 33: Entretien
Français 9. Entretien L’entretien, le remplacement ou la réparation du dispositif et des systèmes de lutte contre les émissions peuvent être effectués par toute société ou individu spécialisé dans la réparation des moteurs hors-route. ■ TABLEAU D’ENTRETIEN Toutes les Toutes les Toutes les Système/Composant Procédure Avant... - Página 34 English 9. Maintenance ■ REFILLING TRIMMING LINE (■ REMPLISSAGE DU FIL DE TAILLE) (■ LLENADO DEL CABLE COMPENSACIÓN) 3.8m (12.5') 7.6m (25')
- Página 35 9. Maintenance WIND THIS LINE SIDE UP THIS SIDE UP...
-
Página 36: Air Filter
For a replacement plug, use the correct type specified by RedMax/ZENOAH(See SPECIFI- CATIONS on the page 4). (MA3) • When you take off the spark plug, twist (1) and pull off the cap (2). - Página 37 Para una bujía de n’utiliser que le type approprié spécifié par repuesto, utilice el tipo correcto especificado por RedMax/ZENOAH. (MA3) RedMax/ZENOAH. (MA3) • Pour retirer la bougie d’allumage, tournez (1) et • Cuando vaya a retirar la bujía de encendido, gire (1) retirez le bouchon (2).
-
Página 38: Spark Arrester
English 9. Maintenance ■ MUFFLER WARNING • Inspect periodically, the muffler for loose fasteners, any damage or corrosion. If any sign of exhaust leakage is found, do not use the brushcutter and have it repaired immediately. • Note that failing to do so may result in the engine catching on fire. -
Página 39: Ventilación De Refrigeración Del Aire
Français Español 9. Entretien 9. Mantenimiento ■ SILENCIEUX ■ SILENCIADOR AVERTISSEMENT ADVERTENCIA • Vérifier régulièrement l’état du silencieux : • Inspeccione periódicamente el silenciador por si dommages, corrosion et fixation. Si le silencieux hubiera fijadores sueltos o cualquier daño o fuit, arrêter d’utiliser la machine et la faire corrosión. - Página 40 English 9. Maintenance IMPORTANT • If waste gets stuck and causes blockage around the intake air cooling vent or between the cylinder fins, it may cause the engine to overheat, and that in turn may cause mechanical failure on the part of the brushcutter.
-
Página 41: Rangement
Français Español 9. Entretien 9. Mantenimiento IMPORTANT IMPORTANTE • Si des détritus se coincent et bouchent la zone aux • Si el desecho se apila y causa un bloqueo alrededor alentours de l’ouïe d’entrée d’air de refroidissement del conducto de ventilación de refrigeración del aire ou des ailettes de cylindres, le moteur risque de de admisión o entre las aletas del cilindro, puede chauffer et provoquer une grave panne mécanique. -
Página 42: Troubleshooting Guide
English 12. Troubleshooting guide Case 1. Starting failure CHECK PROBABLE CAUSES ACTION ➞ ➞ fuel tank incorrect fuel drain it and with correct fuel ➞ ➞ fuel filter fuel filter is clogged clean ➞ ➞ carburetor adjustment screw out of normal range adjust to normal range ➞... -
Página 43: Liste Des Pièces
RedMax/ uniquement les pièces de the parts list for repair and/or ZENOAH genuinas según se marque RedMax/ZENOAH replacement. especifica en la lista de piezas. comme précisé dans la liste 2. RedMax/ZENOAH does not 2. -
Página 44: Parts List
13. Parts list Fig.1 DRIVE UNIT BT250 (S/N 40400101 and up) - Página 45 Fig.1 DRIVE UNIT BT250 (S/N 40400101 and up) Key# Part Number Description Q'ty Key# Part Number Description Q'ty BT25-50810 PIPE COMP. BT25-50710 DRIVE SHAFT BT25-50910 HOUSING ASSY BT25-50610 GRIP BT25-50510 LEVER ASSY BT25-50520 SCREW 1855-82100 CABLE ASSY BT25-80100 TUBE BT25-50400 HANDLE ASSY BT25-50410 •...
- Página 46 13. Parts List Fig.2 ENGINE UNIT BT250 (S/N KU40001 and up)
- Página 47 Fig.2 ENGINE UNIT BT250 (S/N KU40001 and up) Key# Part Number Description Q'ty Key# Part Number Description Q'ty 6634401 SCREW 3099904 COVER ASSY 3075406 FRONT HOUSING 5946101 KNOB 6635301 SCREW CLUTCH 9506501 DECAL 6969601 WASHER CURVED 9506009 DECAL(To Start) 3075603 CLUTCH ASSY 9506011 DECAL(caution) 6969501 WASHER PLAIN 8714402 SPARK PLUG...
- Página 48 THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS, AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE. IF YOU NEED TO OBTAIN INFORMATION ABOUT THE NEAREST SERVICE CENTER, PLEASE CALL RedMax/ZENOAH AMERICA INC. AT (770)-381-5147. IMPORTANT: YOU WILL RECEIVE A WARRANTY REGISTRATION CARD AT TIME OF PURCHASE.PLEASE FILL OUT THE CARD AND SEND IT TO RedMax / ZENOA AMERICA WITHIN SEVEN (7) DAYS.BE SURE TO KEEP...
-
Página 49: Garantie Limitée
AMERICA INC. au (770)-381-5147 Note importante: vous recevrez une carte d'enregistrement de garantie au moment de l'achat. Veuillez la remplir et l'adresser à RedMax / ZENOAH AMERICA sous sept (7) jours en prenant soin de conserver une copie pour vous. ZENOAH AMERICA, INC. -
Página 50: Garantía Limitada
ZENOAH AMERICA, INC. LLAMANDO AL (770)-381-5147. IMPORTANTE: RECIBIRÁ UNA TARJETA DE REGISTRO DE GARANTÍA EN EL MOMENTO DE LA COMPRA. LLENE LA TARJETA Y ENVÍELA A RedMax / ZENOAH AMERICA DENTRO DE SIETE (7) DÍAS. ASEGÚRESE DE CONSERVAR UNA COPIA PARA SUS REGISTROS. - Página 52 ZENOAH AMERICA, INC. 1100 Laval Blvd. Suite 110 Lawrenceville, Georgia 30043 Printed in U.S.A.