Solo 630 Manual De Empleo página 26

SELF HELP TIPS
Engine will not start
Chain will not move
Chain moves at idling speed
Excessive smoke in exhaust gas
Chain cuts poorly
No chain lubrication
MAINTENANCE CHART
Service
Complete saw
Guide bar
Saw chain
Chain brake
Chain lubrication
Chain sprocket / clutch
Clutch drum
Air filter
Air inlet
Cylinder cooling fins
Carburetor
Spark plug
Fuel mix tank
Oil tank / Oil filter
Cylinder screws
Exhaust Screws
Other accessible screws and nuts
- No spark
- No fuel
- Stale fuel
- Ignition switch off
- Spark plug dirty
- Chain brake engaged
- idling speed too high
- clutch damaged
- Carburetor adjustment too rich
- Excessive oil in mixture
- air filter clogged
- Partially closed choke
- Saw Chain blunt
or incorrectly sharpened
- Carburetor setting incorrect
- Air filter clogged
- Oil tank empty
- Oil exit port to bar blocked
- Clogged oil filter in tank
For extended service life and to prevent damage, the following service work should be carried out as
scheduled. Warranty claims are valid only if such maintenance work has been done properly and regularly
Visual check / General condition
Clean exterior
Operation check
Turn over guide bar
Check for wear and damage
Grease sprocket nose
Clean bar groove and oil inlet port
Clean inside of bar cover
General check / check sharpness
Check tension
Check operation
Clean
Adjust
Check
Check
Grease bearing
Clean
replace
clean
clean
Adjust
Check idling speed and re-adjust if required
(chain should not move)
adjust / replace
clean / flush with petrol
clean
Check/Retighten
Check
Check and tighten
- Replace spark plug
- Refuel
- Flush tank, refuel with fresh mix
- Set switch to "I"
- Clean or replace
- Release chain brake
- Turn idling set screw (T)
anti-clockwise
- Replace clutch
(see Service Center)
- Retune carburetor
- improve fuel mixing procedure
- Clean or replace
- Open choke fully
- sharpen saw chain
- Tune with warm engine
- Clean or replace
- Refill oil tank
- Clean
- Clean or replace
After each
fueling
X
X
X
X
X
26
As re-
Daily Weekly Monthly
quired
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
X
See
Page
24
24
23
23
24
24
X 24
28
24
24
24
X
24
X
24
X
X
25
26
28
X
25