Operating­wIth­DIsposable­PRopane­CYlinders; Maintenance - Mr. Heater MH4B Instrucciones Del Usuario

LIGHTING / OPERATING INSTRUCTIONS
WARNING: Always­inspect­propane­cylinder­and­heater­
propane­connections­for­damage,­dirt,­and­debris­before­
attaching­propane­cylinder.­Do­not­use­if­head­of­cylinder­is­
damaged,­punctured­or­deteriorated.­
ALWAYS­ATTACH­OR­DETACH­CYLINDER­OUTDOORS­
AWAY­FROM­FLAMES,­OTHER­IGNITION­SOURCES,­AND­
ONLY­WHEN­HEATER­IS­COOL­TO­TOUCH.­NEVER­SMOKE­
WHEN­ATTACHING­OR­REMOVING­PROPANE­CYLINDER­OR­
MAKING­REMOTE­CONNECTIONS!
•­
Use­only­LP-gas­cylinders­marked­in­accordance­with­the­
U.S.­Dept.­of­Transportation­(DOT).
•­
Use­only­16.4­oz.­(1­lb.)­disposable­cylinders­that­mate­
with­No.­600­valve­connection.­
•­
Heater­and­attached­cylinder­must­be­in­an­upright­
position­during­operation.
•­
Screw­1­lb.­disposable­LP-gas­supply­cylinder­clockwise­
(from­bottom)­into­portable­heater­until­hand-tight­and­
fit­cylinder­into­stand.­Do­not­use­thread­sealant­on­this­
connection.
•­
Check­cylinder­connection­for­leaks­with­soapy­water­
at­the­threaded­connection­under­the­domed­plastic­
cover­where­the­cylinder­screws­into­the­regulator.­SEE­
WARNING!­ON­PLASTIC­COVER.
•­
Depress­"ON"­button­to­light­pilot­flame­(repeat­until­
pilot­lights)­and­continue­to­hold­for­30-60­seconds.
•­
After­lighting­pilot,­release­"ON"­button­to­light­heater.
•­
To­shut­off­heater,­press­the­"OFF"­button.
•
CAUTION: After­turning­heater­off,­wire­guard­will­
remain­hot.­Allow­to­thoroughly­cool­before­storing.
•­
Do­not­operate,­store­or­remove­cylinder­near­
flammable­items­or­ignition­sources.
•­ LP-GAS­CYLINDERS­MUST­BE­DISCONNECTED­FROM­
HEATER­WHEN­NOT­IN­USE!

MAINTENANCE:

Always­keep­the­heater­area­clear­and­free­from­
combustible­materials,­gasoline­and­other­flammable­
vapors­and­liquids.­­
Keep­the­vent­areas­(slots­in­the­bottom­and­top­of­the­
heater)­clear­at­all­times.
Visually­inspect­the­pilot­flame­and­burner­periodically­
during­use.­­The­pilot­flame­should­be­blue­in­color­(not­
yellow)­and­will­extend­to­the­thermocouple.­The­flame­will­
surround­the­thermocouple­just­below­the­tip,­see­Figure­2.
A­slight­yellow­flame­may­occur­where­the­pilot­flame­
and­main­burner­flame­meet.­The­burner­should­be­bright­
orange­(with­a­slight­blue­color­around­the­border,­a­red-
orange­haze­that­is­visible­on­the­ceramic­tile­is­acceptable)­
and­without­a­noticeable­flame.
Pilot Flame
Oxygen Depletion Sensor
Figure 2
A­blue­flame­that­rolls­out­at­the­top­of­the­ceramic­tile­
indicates­an­accumulation­of­dust,­lint­or­spider­webs­
inside­the­housing­assembly­and­main­burner­assembly.­­If­
the­pilot­is­yellow­or­the­burner­has­a­noticeable­flame,­
cleaning­may­be­required.­­Use­the­following­procedure­to­
inspect­the­casing­assembly­and­main­burner­assembly.­­It­
is­necessary­to­periodically­check­the­burner­orifice­and­
burner­venturi­to­make­sure­that­they­are­clear­of­things­
such­as­insect­nests­and­spider­webs­that­may­accumulate­
over­time.­A­clogged­tube­can­lead­to­a­fire.
CLEANING­INSTRUCTIONS:
1.­ ­Allow­heater­to­thoroughly­cool­before­performing­
2.­ ­Remove­disposable­1­lb.­propane­cylinder­from­
3.­ ­Remove­right­side­plastic­service­panel­(ref.5)­by­
4.­ ­Inspect­the­interior­of­casing­for­accumulation­of­
5.­ ­Inspect­and­clean­main­burner­(ref.­13)­and­orifice­
6.­ ­Inspect­and­clean­pilot­tube­(ref.­14).­Insert­a­
WARNING:­Never­use­needles,­wires­or­similar­cylindrical­
7.­ ­Apply­compressed­air­(max­30­psi)­into­the­ceramic­
8.­ ­Reinstall­the­right­side­plastic­service­panel.
4
Mr. Heater MH4B Operating Instructions and Owner's Manual
any­maintenance.
heater.
removing­the­six­screws­holding­it­in­place.
dust,­lint­or­spider­webs.­­If­necessary,­clean­the­
interior­of­the­casing­assembly­with­a­vacuum­cleaner­
or­compressed­air­(max­30­psi).­­Do­not­damage­any­
components­within­the­casing­assembly­when­you­
are­cleaning.
(ref.­3)­by­using­a­vacuum­or­compressed­air­(max­30­
psi).­
doubled­over­pipe­cleaner­into­the­pilot­tube­until­
it­bottoms­against­the­pilot­orifice­(approximately­
2").­­Rotate­the­pipe­cleaner­a­couple­of­times­
and­remove.­­Blow­out­the­remaining­debris­using­
compressed­air.
objects­to­clean­the­pilot­to­avoid­damaging­the­
calibrated­ruby­that­controls­the­gas­flow­through­the­
pilot­orifice.
tile­of­burner­assembly­and­venturi­tube­(ref.­13)­to­
remove­dust,­lint­and­spider­webs.