Troubleshooting; Technical Data - Cramer 7400086 Manual De Instrucciones

Troubleshooting

EN
PROBLEM PROBABLE CAUSE
The battery is not
properly installed.
Lock-out button has
The utility cart timed out.
does not run.
Power switch is off.
The controller is
damaged.
The cable connector
gets separated.
Battery volume is low.
The utility The battery does not
cart runs accept full charge.
sluggishly.
Too much weight or
slopes too steep.
Sometimes
the utility
Damaged or worn
cart runs, but
electrical switches.
other times it
does not.
Loud clunking
or grinding The motor's gears are
noise from broken.
the gearbox.
* If the fault is not solved, you must go to your distributor and/or nearest Authorized
Technical Service.
10
cramer.eu
POSSIBLE SOLUTION *
To secure the battery pack,
make sure the latch on bottom
of the battery pack snaps into
place.
Press and hold the lock-out
button, and then thumb paddle.
Turn on power switch.
Contact an authorized service
center.
Connect the cable connector
into place.
Charge the battery pack
according to the instructions.
Replace the battery with a new
82 Volt battery.
Reduce the weight in the
bucket; operate on slopes that
are less steep.
Contact an authorized service
center.
Contact an authorized service
center.

Technical Data

PROPERTY
Norminal voltage: 72V
Rating
Rating power: 300W
150kg up to 5 degrees slope.
Loading capacity
100kg up to 16.7 degrees slope.
Inflation pressure 22 psi (1.5 bar) to 30 psi (2.0 bar)
Weight (tool only) 40kg(±2kg)
Capacity (Volume) 106L / 3.74CUFT
Length 51.8" (131.5cm)
Width 26.4" (67cm)
Height 43.3" (110cm)
High: 5.2 km/h (±0.5km/h)/ 3.2 mph (±0.31 mph)
Low: 4.0 km/h (±0.5km/h)/ 2.5 mph (±0.31 mph)
Speed
Reverse: 3.0 km/h (±0.5km/h)/ 1.86 mph (±0.31
mph)
Front Tire 12x5.0-6" Pneumatic wheel
Rear Tire 8" Solid caster wheel
Oil type Automatic Transmission Fluid
Oil capacity 150ML
Battery pack 82V220G/82V430G/82V220/82V430
Charger 82C1G/82C2/82C6
Sound pressure level < 70 dB(A)
Vibration level < 2.5 m/s
VALUE
2