Operation - Textron Greenlee Ultra Tugger 15000-22 Manual De Instrucciones

Tabla de contenido

Publicidad

Idiomas disponibles
  • MX

Idiomas disponibles

Operation

1. Fish the rope through the conduit.
2. Set up the cable puller. See "Typical Setups" illustra-
tions and instructions in this manual.
Set up the cable puller so that the rope will ap-
proach the capstan at an angle of 90° (±5°).
Angles outside of this range may cause the rope to
overlap.
90° (±5°)
3. Set the rope ramp as follows:
a. Wind the rope several times around the capstan.
b. Pull the ramp away from the mounting plate and
rotate it until the flat surface contacts the rope.
Greenlee / A Textron Company
®
Ultra Tugger
Cable Puller and Pulling Packages
4. Check the I/O switch on the puller to be sure it is
5. Connect the force gauge to an appropriate power
6. Position the force gauge so that it can be monitored
Duty Cycle Table
7. Turn the circuit breaker in the force gauge ON (I).
8. Grasp the tailing end of the rope. Apply a slight
9. Turn the puller ON (I).
10. Tail the rope, allowing the spent rope to accumulate
11. When the pull is complete, turn the puller OFF (O).
40
c. Push the ramp toward the mounting plate and
rotate it counterclockwise until it locks into place.
OFF (O). Plug the puller into the receptacle of the
standard force gauge.
supply (see "Grounding Instructions" in this manual).
Note: If using an extension cord, it must be rated for
20 amps. Use the shortest cord possible. Longer
cords reduce puller speed.
by the puller operator.
Color
Band
Pounds of
on Meter
Pulling Force
Green
0 – 13.9 kN (0 – 2500 lb)
Yellow
13.9 – 22.3 kN (2500 – 5000 lb)
Red
over 22.3 kN (5000 lb)
amount of tailing force.
on the floor between the operator and the puller.
Tie off the rope and anchor the cable.
Do not wrap rope around hands,
arms, waist or other body parts.
Do not stand in spent coils or tailed
rope. Hold rope so that it may be
released quickly.
4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070
Duty Cycle
(in minutes)
continuous
5 per hour
puller will stop

Publicidad

Tabla de contenido
loading

Este manual también es adecuado para:

Greenlee ultra tugger 6501-22Greenlee ultra tugger 6505-22

Tabla de contenido