Mase Generators IS 3501 Manual Uso Y Mantenimento página 15

mase
GENERATORS
Code E - 85 This code indicates that the unit has
stopped because the voltage has dropped to below 70%
of the nominal value for longer than 15 seconds.
Code E - 87 This code indicates that the unit has
stopped because the generator voltage has not reached
80% of the nominal value 30 seconds after starting. This
could be caused by insufficient motor RPM or a broken
alternator.
batt This code indicates that the battery
is low. When this code appears, the generator is not
stopped.
WARNING
When a circuit breaker has tripped with a consequent
generator stop, the panel must be reset by pressing the
" OFF" button in order to restart the unit.
INFORMATION
If the unit is started and the alternator does not produce
voltage, or the control panel does not read voltage, the
latter switches off completely after one minute, stopping
the unit.
8 PROTECTION FUSE ( fig. 4 )
1) RELAY CIRCUIT FUSE
2) BATTERY CHARGER FUSE
9 DIMENSIONS AND WEIGHT( fig. 7 )
IS 3501
L) Lengh mm.665 (26.18")
W) Width mm.423 (16.65")
H) Height mm.540 (21.26")
Weight Kg 78 (173lb)
10 DESCRIPTION WIRING DIAGRAM (fig. 8 )
1 ROTOR
2 STATOR
3 DIODE 3A
4 VARISTOR
5 PRINTED CIRCUIT RELAY
6 POWER TERMINAL BOARD
7 RELAY CIRCUIT TERMINAL BOARD
8 CONTROL PANEL TERMINAL BOARD
9 FUSE 1A
10 CAPACITOR
11 BATTERY CHARGER REGULATOR
12 FUSE 20A
13 STARTER
14 BATTERY
15 FUEL PUMP
16 FUEL SOLENOID
17 OIL PRESSURE SWITCH
18 OVERHEAD ENGINE THERMOSTAT
19 WATER TERMOSTAT
20 ALTERNATOR THERMOSTAT
GB
IS 4501-5501
mm.733 (28.8")
mm.485 (19")
mm.578 (22.7")
kg 110 (244.4 lb)
IS 3501 - 4501- 5501
11 TROUBLE MAINTENANCE
12 TROUBLE SHOOTING
COMPLAINT
PROBABLE REASON
Defective starting buttons
Defective fuel solenoid
Defective battery Battery
cable section
Defective starting motor
Piping fuel filter choked
12V circuit fuse
Avv./Ev.relay
Too much oil in crankcase
Safety device intervention
Overload
Defective governor linkage
Worm valve guides
Blocked valves
Worm cylinder and position rings
Defective injector
Defective injector pump
Defective feeding pump
l
l l
l
l
l l
l
l
l l
l l
l
l
l
l
l
l l
l l l l
l l
-
15
-