Char-Broil PERFORMANCE T-35G4 Guía Del Producto página 33

EMERGENCIES; if a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.
Gas leakingfrom
cracked/cut/burned hose.
Gasleaking from LPcylinder.
Gasleaking from LP
cylinder valve.
Gasleaking betweenLP
cylinder and regulator
connection.
Fire comingthroughcontrol
panel.
Greasefire or continuous
excessiveflamesabove
cookingsurface.
. Damagedhose.
. Mechanical f ailure due to rusting or mishandling.
. Failureof cylindervalvefrom mishandlingor
mechanical f ailure.
. Improperinstallation,connectionnot tight, and/or
failure of rubber seal.
. Fire in burnertube section of burner dueto blockage.
. Too muchgreasebuildupin burner area.
.Turn offgas at LP cylinderor at source on naturalgas systems. Discontinueuse of
productand replace valve/hose/regulator.Oncevalve/hose/regulator r eplaced
conductcompleteleak check per manual.
. ReplaceLPcylinder.
. Turnoff LPcylinder valve. Return LPcylinder to gas supplier.
. Turnoff LPcylindervalve. Removeregulatorfrom cylinder andvisually inspect rubber
sealfor damage.See LP CylinderLeak Testand ConnectingRegulatorto the LP
Cylinder.
. Turnoff controlknobs and LPcylinder valve. Leave lid opento allow flamesto die
down.After fire is out and grill is cold, removeburner and inspectfor spider nestsor
rust.See NaturalHazardand Cleaningthe BurnerAssemblypages.
. Turnoff control knobsand LPcylinder valve. Leave lid opento allow flamesto die
down.After cooling, cleanfood particlesand excessgreasefrom insidefirebox area,
greasetray, andother surfaces.
Troubleshooting
Burner(s)will not light
usingignitor.
(See ElectronicIgnition
Troubleshooting also)
Continuedon next page.
Burner(s)will not match light.
GAS iSSUES:
. Tryingto lightwrong burner.
. Burnernot engagedwith controlvalve.
. Obstructionin burner.
. No gas flow.
. Seeinstructionson control panel and in UseandCare section.
. Makesure valvesare positionedinsideof burnertubes.
. Ensure burnertubes are notobstructedwithspider websor other matter.See
cleaning sectionof Useand Care.
. Makesure LP cylinderis not empty.If LPcylinder is not empty,referto
"Suddendrop in gas flow."
. Vaporlockat coupling nutto LPcylinder.
. Couplingnutand LP cylindervalve notfully
connected.
ELECTRICALiSSUES:
. Electrodecrackedor broken;"sparks at crack."
. Turnoff knobsand disconnectcoupling nutfrom LP cylinder.Reconnectand retry.
. Turnthe coupling nutapproximatelyone-half to three-quartersadditionalturn until
solidstop. Tightenbyhand only - do not use tools.
. Replaceelectrode(s).
. Electrodetip not in proper position.
(Doesnot applyto SUREFIRE.)
. Wireand/orelectrodecoveredwith cooking residue.
. Wiresare looseor disconnected.
. Wiresare shorting(sparking)betweenignitorand
electrode.
. Deadbattery.
ELECTRONIC IGNITION:
. Nospark, no ignition noise.
. Nospark, some ignition noise.
. Sparks, but notat electrodeor at full strength.
. See "GAS ISSUES:".
. Matchwill not reach.
. Impropermethodof match-lighting.
Main Burners:
. Tip of electrodeshouldbe pointingtowardgas port openingon burner.The
distanceshouldbe 1/8"to 1/4".Adjustif necessary.
Sideburner:
. Tipof electrodeshouldbe pointingtowardgas port openingon burner,the
distance shouldbe 1/8" to 3/16".Adjust if necessary.
. Cleanwire and/or electrodewith rubbingalcoholand clean swab.
. Reconnect w ires or replace electrode/wire assembly.
. Replaceignitorwire/electrodeassembly.
. Replacewith a new alkalinebattery.
. SeeSectionI of ElectronicIgnitionSystem.
. SeeSectionII of ElectronicIgnitionSystem.
. SeeSectionIII of ElectronicIgnitionSystem.
. Uselong-stemmatch(fireplacematch).
. See "Match-Lighting" s ection of Useand Care.
33