Clarion CMS4 Manual De Instrucciones Y Manual De Instalación página 13

4. BLACK BOX INSTALLAION
1. Select an area with sufficient ventilation for the mounting of the black box in order to prevent the module
from overheating. You may mount the black box in a horizontal or vertical position. If the black box is
mounted in a vertical position, do not mount the module with the harness exit points directly facing up to
prevent water collecting in these areas.
2. Please refer to the diagram below for the mounting screw hole positions. Always use the shortest length
of screw possible.
3. During installation, use the 6 rubber mounting stoppers (included in the package) for the bottom of the
module. This provides clearance from surface moisture and provides sufficient ventilation for the heat
sink.
4. Extension wires/cables may be needed to route the harness and cable throughout the vessel.
Note: Retain some slack in the harness/ cables to prevent damage to the wires. It is recommended relieve
stress in all cables and harnesses.
5. Always read through the wiring diagram in this manual first, and follow all the wiring diagrams carefully.
The connections should be secured and insulated with crimp connectors or electrical tape to ensure
proper connections.
6. Once the wiring connections are completed, connect the negative terminal on the battery, turn the
vessel accessory ON and power on the unit to check if it is operating correctly. If abnormalities
occur, disconnect the battery negative terminal, recheck all wiring and try again. Please refer to the
troubleshooting section for assistance.
BLACK BOX MOUNTING
24
CMS4
5. WIRE CONNECTION
Black
ANTENNA
Steering Wheel
Black
SWC
Remote Control
Terminal
Black-Subwoofer
Grey
FRONT/ZONE1
Red-Line Out Right
White-Line Out Left
White-Line Out Left
Black
REAR/ZONE2
Red-Line Out Right
Black-Subwoofer
White-Line Out Left
Purple
Red-Line Out Right VARIABLE/ZONE3
Black-Subwoofer
White-Line Out Left
Green
FIXED/ZONE4
Red-Line Out Right
Black-Subwoofer
Red
Red-Aux In Right
AUX IN
White-Aux In Left
Bluetooth Antenna
Brown
RED
15 PIN MOLEX Connector
FUSE 15 A
ORIENTATION
1 2 3 3 2 1
4 5 6 6 5 4
7 8 9 9 8 7
10 11 12 12 11 10
13 14 15 15 14 13
SECTION A-A SECTION B-B
PIN NO. WIRE COLOR WIRE DEFINTION AWG
1 GREEN SPEAKER REAR LEFT (+) 20
2 GREEN/BLACK SPEAKER REAR LEFT (-) 20
3 RED ACCESSORY/IGNITION SWITCHED (+12V) 20
4 WHITE SPEAKER FRONT LEFT (+) 20
WHITE/BLACK
5 SPEAKER FRONT LEFT (-) 20
6 YELLOW BATTERY (+12V) 16
7 GREY SPEAKER FRONT RIGHT (+) 20
8 GREY/BLACK SPEAKER FRONT RIGHT (-) 20
9 BLUE/WHITE AMPLIFIER REMOTE TURN ON (+) 20
10 PURPLE SPEAKER REAR RIGHT (+) 20
11 SPEAKER REAR RIGHT (-)
PURPLE/BLACK 20
12 BLACK GROUND (-) 16
13 ORANGE/WHITE (+12V)DIMMER 20
14 PURPLE/WHITE CAMERA TRIGGER (+) 20
15 BLUE POWER ANTENNA 20
DISPLAY CONTROLLER
Black
USB 2.1A/BB UPDATE
Black
WIRED REMOTE 1
Black
WIRED REMOTE 2
Black
WIRED REMOTE 3
Black
WIRED REMOTE 4
Black
DISPLAY CONTROLLER
Black
SIRIUS XM
15 PIN MOLEX
Connector
Wire Code
BLUE RED
PURPLE/WHITE GREEN/BLACK
ORANGE/WHITE GREEN
BLACK YELLOW
PURPLE/BLACK WHITE/BLACK
PURPLE WHITE
3048mm (10 feet)
BLACK BOX
Extension Cable
Female Male
DISPLAY CONTROLLER UPDATE
YELLOW
CAMERA
Female
25
CMS4