Berkel BF+15F Manual De Uso Y Manutención página 36

-
After having connected the machine to the electrical line press the start push
button "1" fig. 6.2.1 .
-
Lift the pedal and wait for the plug to reach the limit.
-
Loosen the ring nuts "4" that block the cover by a few turns. Lift the cover and
turn it sideways as in fig. 6.2.1.
-
Fill the cylinder "7" with mixture so that the plug "8" is in a low position.
-
Replace the cover in its proper seating and block it with the corresponding ring
nuts. Check that the sealing gasket has not come out of its proper seating.
-
After having chosen and assembled the exit funnel by means of the ring nut
"9", fig. 6.2.1 push the start push button "1".
-
Press the pedal and the plug will start the work run by pushing the mixture to-
wards the exit funnel. The speed is determined by the tap "2".
Turning it clockwise lowers the plug pushing speed while turning it coiunter-
clockwise increases the speed.
-
When the content of the cylinder is finished bring the plug into its initial position
by lifting the pedal (fig. 6.2.1).
7 Maintenance
7.1 - Prescriptions
Every maintenance and cleaning intervention on the sack filling machine must be
carried out only when the machine is stopped and disconnected from the electrical
power supply.
The area where maintenance is done must always be kept clean and dry.
Do not allow unauthorized personnel to intervene on the machine.
Any replacement of parts must be done with original spare parts at authorized wor-
kshops or directly by the manufacturer.
Make sure that all the parts of the hydraulic circuit have been closed properly.
Before disassembling pipe fittings or piping make sure there is no fluid under pres-
sure: the oil that comes out under pressure could cause serious damage.
If there is damage or fluids that come out of the piping, etc. are accidentally swallo-
wed, immediately contact a doctor.
In particular remember that: the fluid that comes out of a very small hole can be
almost invisible and have enough force to penetrate the skin. Use a card or piece
of wood to look for leaks.
Never use your hands !!!
If the fluid comes into contact with the skin immediately contact a doctor. In fact
serious infections or skin problems could develop if prompt medical treatment is
not sought.
ATTENTION!
18