Hitachi Koki EC 2610E Manual De Instrucciones Y Instrucciones De Seguridad página 9

2. Location
WARNING
: In order to avoid damaging this
compressor, do not incline this
compressor
longitudinally more than 10°.
Place this compressor at least 4 inches away from
obstacles that may prevent proper ventilation. Do not
place this compressor in an area:
- where there is evidence of oil or gas leaks.
- where fl ammable gas vapors or materials may be
present.
- where air temperatures fall below 32°F or exceed
95°F.
- where extremely dirty air or water could be drawn into
this compressor.
CAUTION: When operating or storing the compressor,
set 4 rubber bumpers downward on the
fl oor (Refer to Fig. 1).
Excessive vibration is a major cause of
premature compressor failure.
Always maintain the rubber bumper located
beneath tank.
3. Gasoline engine
A) Review page 6. 27 before fueling.
WARNING
: Do not allow the engine or muffl er
to come in contact with fl ammable
vapors,
or other combustible materials. A
spark may cause a fi re. Do not place
this compressor in an area where
fl ammable gas vapors may be present.
B) Read the engine manual accompanying this
compressor for correct engine start-up maintenance
procedures.
C) Read and understand the safety labels located on
this compressor.
D) A minimum of 85 octane fuel is recommended
for use with this compressor. Do not mix oil with
gasoline.
E) Use of clean, fresh, lead free gasoline should be
used. Do not use gasoline containing methanol or
alcohol.
F) Check the engine oil level before starting (See
engine manual).
G) Fill the fuel tank according to the engine manual
instructions.
WARNING
: Follow all fueling instructions in
operator's
extremely fl ammable, and gasoline
vapor can explode. Do not refuel
fuel tank while this compressor is
running or hot. Never smoke near
gasoline, and keep other fl ames and
sparks away. Allow this compressor
and engine to cool down before
refueling. Do not refuel indoors or
in a poorly ventilated area. Do not
fi ll fuel tank to point of overfl owing.
Always refuel slowly to avoid the
possibility of spilled fuel which may
000Book_EC2610E.indb 9 000Book_EC2610E.indb 9
transversally or
combustible dust, gases
manual. Gasoline is
— 9 —
cause a fi re. Do not operate this
compressor if gasoline is spilled.
Wipe this compressor clean and
move it away from the spill. Avoid
creating
gasoline
approximately 1/4" of tank space for
fuel expansion. Always store fuel
away from this compressor while
it is running or hot. Always store
gasoline in an approved container.
H) Refer to the engine manual for all necessary
maintenance and adjustments.
WARNING
: Do not operate this compressor in an
enclosed area. Use this compressor
only in well ventilated areas. The
exhaust from the engine contains
carbon monoxide,
odorless and invisible gas. Breathing
the gas can cause serious injury,
illness and possible death. Avoid
inhalation of exhaust gas. Never
run the engine in a closed garage or
confi ned area.
4. Air coupler installation
Screw in the air coupler to the joint (Refer to Fig.1 and
Fig.5). The screw size of the joint is 3/8". Use an air
coupler which has the same screw size.
5. Pre-start checklist
A) Make sure the engine switch is in the "OFF" position.
B) Remove any moisture in this compressor air tank.
Gradually open the drain cock and discharge the
drain. Close tightly when drained.
C) Make sure the safety valve is working correctly (refer
to Fig.1). The safety valve is designed to prevent
system failures by relieving pressure from the system
when this compressed air reaches a predetermined
level. The safety valve is preset by the manufacturer
and must not be modifi ed in any way.
Before starting the compressor, pull the ring on
the safety valve to make sure that the safety
valve operates smoothly. (Fig. 7) Do not use the
compressor if the safety valve is stuck or does not
operate smoothly. Have the defective safety valve
replaced by a Hitachi authorized service center.
Fig. 7
WARNING
: Drain tank to release air pressure
before pull the ring on the safety
valve.
English
any ignition until the
has evaporated. Allow
a poisonous,
Safety valve
2016/01/25 10:56:31 2016/01/25 10:56:31