MrHeater MH125KTFR Instrucciones De Uso Y Manual Del Usuario página 4

3.­ Next­install­the­heat­shields.­These­are­attached­centered­at­
the­12­o'clock­and­6­o'clock­positions.­The­larger­one­will­be­
installed­at­the­bottom.­These­are­fastened­into­place­using­
the­screws­holding­the­radiant­heating­surface­plate­in­place.­
Simply­loosen­only­the­necessary­screws­attach­the­shields­
and­tighten­the­screws­back­into­place.­
MH70KTFR
1.­ First­Locate­the­hardware­package.­You­will­find­four­long­
screws­for­the­base­tubing,­along­with­4­nuts­and­washers.­
Place­the­heater­on­the­base­tubing­as­shown­on­the­front­of­
this­manual­or­in­the­parts­diagram.­Use­the­long­screws­and­
matching­fasteners­to­attach­the­base­to­the­fuel­tank.
2.­ In­the­hardware­package­you­will­also­find­two­shorter­
washer­headed­screws­for­attaching­the­handle­to­the­top­of­
the­heater.­Using­a­Phillips­headed­screw­driver,­attach­the­
handle­to­the­top­of­the­heater­as­shown­on­the­front­of­this­
manual­or­in­the­parts­diagram.­­
3.­ Finally­install­the­lower­heat­shield.­The­included­heat­shield­
will­be­located­centered­at­the­6­o'clock­position.­Only­two­
screws­are­used­to­hold­the­shield­in­place.­The­middle­hole­
is­only­for­the­locating­pin­that­receives­no­fastener.­Simply­
remove­the­screws­that­line­up­with­the­holes­on­the­heat­
shield­when­on­the­centering­pin.­Put­the­heat­shield­into­
place­and­re-attach­the­screws.­
PREPARING FOR OPERATION
1.­ Check­the­heater­for­possible­shipping­damage.­If­any­is­
found,­immediately­contact­the­manufacturer­at­
800-251-0001.
2.­ Follow­all­of­the­"Precautions".­
3.­ Fill­the­fuel­tank­with­clean­kerosene.­In­extremely­cold­
weather,­condensation­may­develop­in­the­tank­and­it­is­
recommended­that­a­tablespoon­of­de-icer­be­added­for­
each­gallon­(4­liters)­of­fuel­in­the­tank.­When­filling­the­
heater,­use­at­least­2­gallons­(8­liters)­of­fuel.­Be­sure­heater­
is­level­and­do­not­overfill.­Use­a­funnel­or­can­with­a­long­
fill­spout.
IMPORTANT: Before filling fuel tank the first time or after
extended storage periods, drain the fuel tank of any
moisture or condensation.
4.­ Locate­heater­at­a­safe­distance­from­combustible­materials.­
Refer­to­the­specifications­table­in­this­manual­for­distances.­
HEATER START UP
1.­ Locate­the­power­plug­near­the­controls­of­the­heater.­Using­
a­properly­sized­and­grounded­extension­cord­plug­in­the­
unit.
2.­ When­power­reaches­the­heater­the­Red­light­on­the­back­of­
the­heater­will­illuminate.­
3.­ Turn­the­power­switch­to­the­ON­position.­The­LED­read­out­
will­show­the­approximate­room­temperature.­When­you­turn­
the­thermostat­knob­clockwise­the­LED­readout­will­change­
to­show­the­set­temperature.­When­that­number­is­higher­
than­the­room­temperature­the­heater­will­begin­is­sequence­
of­operation.­
4.­ Once­the­heater­begins­to­run­it­will­cycle­on­and­off­based­
on­the­thermostat­setting.­If­for­any­reason­your­heater­does­
not­run­properly­refer­to­the­Diagnostic­and­trouble­shooting­
section­in­this­manual­or­contact­the­manufacturer­with­one­
of­the­methods­listed­on­the­back­page­of­this­manual.­
HEATER SHUT DOWN
1.­ To­turn­off­either­turn­the­thermostat­knob­to­a­temperature­
lower­than­the­room­temperature­or­move­the­power­switch­
to­the­off­position.­These­heaters­are­engineered­with­an­
Mr. Heater, Inc. | Kerosene Fired Radiant Heater
integrated­3­minute­cooling­cycle­designed­to­prolong­the­life­
of­internal­components­and­to­reduce­surface­temperatures­
that­tend­to­increase­shortly­after­shutdown.­Please­allow­this­
cycle­to­complete­before­removing­power­from­the­heater.­
DAILY SCHEDULE
1.­ GENERAL.­Make­general­visual­inspection­of­heater­for­loose­
or­damaged­parts.­Check­nuts­and­bolts­to­insure­against­
looseness­caused­by­vibration­or­rough­handling.­Damaged­
parts­should­be­repaired­or­replaced­before­using­heater­
again.­Check­heater­operation­to­be­sure­it­is­operating­
normally­(See­"Servicing"­section­for­description­of­normal­
operation).
2.­ FILTERS.­Dirty­fuel­filters­will­cause­an­imbalance­in­the­air-
fuel­mixture.­The­best­indication­that­this­condition­exists­
is­an­increase­in­odors­or­difficulty­getting­your­heater­to­
ignite.­This­heater­should­never­be­operated­without­the­
filter­in­place.­Contact­Mr.­Heater­for­replacement­parts
500 HOUR SCHEDULE
1.­ REMOVE­DUST.­Clean­heater­twice­a­season­(more­often­
under­dusty­conditions).­Remove­accumulated­dust­from­the­
burner,­motor­and­fan­blades­with­compressed­air.­Wipe­area­
clean­with­a­clean­dry­cloth.­Inspect­area­to­insure­all­foreign­
materials­are­removed,­especially­around­the­burner­and­
combustion­area.
2.­ CAD­CELL.­Clean­the­glass­portion­of­the­cad­cell­with­a­soft­
dry­cloth.
3.­ NOZZLE.­Accumulation­of­dirt­and­carbon­from­the­
combustion­process­can­eventually­fill­up­the­passages­in­
the­nozzle,­resulting­in­reduction­of­fuel­and­air­flow.­If­this­
occurs,­replace­the­fuel­nozzle.­Contact­Mr.­Heater­for­service­
parts
4.­ FUEL­TANK.­Clean­twice­a­season­(during­frequently­used­
periods,­clean­twice­a­month).­Drain­and­flush­the­fuel­tank­
with­clean­fuel­oil.
ANNUAL SCHEDULE
1.­ FUEL­FILTER.­Remove­the­fuel­filter­from­fuel­line­and­direct­
compressed­air­through­the­filter­in­the­opposite­direction­
of­fuel­flow.­Safety­glasses­should­be­worn­when­using­
compressed­air.
2.­ FUEL­LINES.­If­the­fuel­lines­are­removed­during­cleaning,­be­
sure­all­connections­are­tight­before­operating­unit.­If­any­dry­
rotting­or­cracking­in­the­lines­is­observed­replace­with­1/4"­
id­fuel­line­or­contact­Mr.­Heater­for­service­parts.­
STORAGE
Store­the­heater­in­a­dry­location­free­from­fumes­or­dust.
At­the­end­of­each­heating­season,­clean­the­heater­as­described­
in­the­MAINTENANCE­section.­Drain­and­flush­the­fuel­tank­with­
clean­fuel.­The­manufacturer­recommends­completely­filling­the­
tank­with­fuel­for­extended­storage­to­minimize­condensation­
inside­the­tank.
SERVICING
A­hazardous­condition­may­result­if­a­heater­is­used­that­has­been­
modified­or­is­not­functioning­properly.­
When­the­heater­is­working­normally:
*­ The­flame­is­contained­within­the­heater.
*­ There­is­no­strong­disagreeable­odor,­eye­burning­or­other­
physical­discomfort.
*­ There­is­no­smoke­or­soot­internal­or­external­to­the­heater.
*­ There­are­no­unplanned­or­unexplained­shut­downs­of­the­
heater.
4
Operating Instructions and Owner's Manual