Espa VIGICOR 150M Manual De Instrucciones página 8

INSTRUCTION MANUAL (Translation from the original Spanish)
A Warning! Observe limitations of use.
B
The name plate voltage must be the same as the
mains voltage.
C Connect the pump to the mains via an omnipolar
switch with at least a 3mm opening between
contacts.
D Install a high-sensitivity differential switch (0.03A)
as extra protection against lethal electric shocks.
E Connect the pump to the ground.
F Use pump only
indicated on the name plate.
G Be careful with
environments.
H Do not carry the pump by the power cable.
Contents
Safety precautions .................................................... 8
1. General information ............................................. 8
2. Handling ............................................................... 9
3. Installation ........................................................... 9
3.1. Fixing .......................................................... 9
3.2. Discharge pipe assembly ........................... 9
3.3. Electrical connection .................................. 9
3.4. Pre-start checks ......................................... 9
4. Starting ................................................................ 9
5. Maintenance ........................................................ 9
6. Nameplate ......................................................... 10
7. Possible faults, causes and solutions ................ 10
8. Technical data ................................................... 10
9. List of main components .................................... 29
10. Illustrations......................................................... 30
Safety precautions
This symbol
following words "Danger" or "Warning" indicates the
risk level deriving from failure to observe the
prescribed safety precautions:
DANGER Warns that failure to observe
the pre cautions involves a risk
risk of
of electric shock.
electric
shock
DANGER Warns that failure to observe
the pre cautions involves a risk
of damage to persons and/or
things.
WARNING
Warns that failure to observe
the pre cautions involves the
risk of damaging the pump
and/or the facility
Damage prevention and safety instructions
(See figure 4)
within performance limits
hazardous liquids
together with one of the
I This apparatus may be used by children older
than 8 and persons with reduced physical,
sensory or mental
experience and
supervised or receive adequate training on the
safe use of the apparatus and understand the
dangers.
Children should not be allowed to play with the
apparatus.
Children should
cleaning and
supervision.
J The pump should only be dismantled by
authorized personnel.
and K Cut out power supply before servicing pump.
L Caution! Avoid icing.
1. GENERAL INFORMATION
Please observe the following instructions to achieve
the best pump performance possible and a trouble
free installation.
Read these instructions before installing the
pump.
Save them for future reference.
The VIGICOR 150M model
single-stage pump with stainless steel grinder for
draining off grey water containing fibrous matter.
The solids passage pitch is approximately 8mm
(MAX).
Maximum water temperature is 35ºC.
Correct pump operation is assured providing
the instructions on electrical connection,
installation and use are strictly adhered to.
Failure to adhere to the instructions can
result in premature failure of the pump and
voiding of the warranty.
The pump cannot be used in a swimming-
pool while there are people bathing.
Do not insert your hand or any other object
into the suction inlet or discharge outlet, as
the rotating turbine and blades could cause
serious injury/damage.
8
capacities, or
knowledge, if they
not perform the ordinary
maintenance tasks
is a submergible,
EN
lacking
are
without