Publicidad
SECCIÓN 5 | DIAGRAMAS DE CABLEADO
5.2 | DIAGRAMA DE CABLEADO DE LOS CONTROLES INFERIORES
Nro. de pieza SUB A8-002
D
C
B
A
Manual de mantenimiento y resolución de problemas
HB-1030/HB-1430
8
MOLEX CONNECTOR
MOTOR CONTROL:
TO MOTOR CONTROL
1 B-
2 B-
3 POT HI (RED)
4 POT WIPER (WHITE)
5 KSI (ORANGE)
9 18
8 17
6
12
6 BRAKE- (BLACK)
5
11
7 16
7 PUSH
6 15
4
10
8 MODE SELECT (BLACK)
3
5 14
9
9 STATUS (GREEN)
4 13
2
8
1 7
3 12
10 B+
2 11
11 B+
1 10
12 INHIBIT
13 POT LO (BLUE)
14 BRAKE+ (BLACK)
15 BDI
16 HORN
17 REVERSE
18 SPEED POT (BROWN)
WIRING SHOWN IN DOTTED LINES IS PART OF
BASE ASSEMBLY, NOT PART OF SUB A8-001
RH BRAKE (YELLOW)
RH BRAKE (YELLOW)
RH BRAKE SWITCH (BLACK)
RH BRAKE SWITCH (BLACK)
GND ELEV/TILT
LIMIT SWITCH
(Located Under Scissors)
TO PH INTERLOCK LIMIT SWITCH (NO)
NC
NO
TO PH INTERLOCK LIMIT SWITCH (NC)
TO MODE LIMIT SWITCH (NO) SIDE
NC
NO
TO MODE LIMIT SWITCH (NC) SIDE
MODE / PH
LIMIT SWITCH
(Located in Base)
14-CONDUCTOR MALE PLUG
ORANGE (5)
FRONT VIEW OF PLUG
BROWN (2)
PURPLE (3)
1
2
3
YELLOW (7)
4
5
6
7
8
9
10
11
12
13
14
TRIM UNCONNECTED WIRES
TO EDGE OF CABLE SHEATH
POWER TO MOTOR CONTROLLER
SUB A8-109
8
THIS DRAWING IS CONFIDENTIAL AND PROPRIETARY TO CUSTOM, EQUIPMENT AND IS LOANED IN EXPECTATION THAT IT
7
BLACK
GREEN
6
12
5
11
ORANGE
4
10
3
9
BLUE
2 8
RED
1
7
BROWN
SUB A8-102
WHITE
23 24
25
26
27 28 29
30
LH BRAKE SWITCH (BLACK)
LH BRAKE SWITCH (BLACK)
LH BRAKE (YELLOW)
LH BRAKE (YELLOW)
GREEN
WHITE
RED
BLACK
SUB A8-106
WHITE
GREEN
BLACK
SUB A8-107
RED
LABEL WIRES AT THIS END OF CABLE. LABEL
BLACK (1)
NUMBERS TO MATCH TERMINAL BLOCK
NUMBERS.
BLUE (6)
RED (14)
WHITE (13)
12C CONN. PINOUT AT UPPER CONTROL:
POT WIPER BLACK
POT HI, SPEED POT BROWN
GREEN (8)
POT LO PURPLE
GRAY (4)
HR/V METER KSI GRAY
TAN (N.C.)
E-STOP 24V+ PWR TO UPR CTL ORANGE
RIGHT TURN LIMIT SWITCH BLUE
PINK (N.C.)
LEFT TURN LIMIT SWITCH YELLOW
PUMP DOWN, DESCENT ALARM GREEN
PUMP SOLENOID, PUMP UP WHITE
24V+ PWR RETURN TO LWR CTL RED
TAN
PINK
BLACK
WHITE
7
28
6
5
DESCENT OR
MOTION ALARM
TILT ALARM
LED
BLACK
GREEN
ORANGE
BLUE
RED
BROWN
WHITE
1
2
3 4
5
6 7 8
9
BLACK (1)
BROWN (2)
PURPLE (3)
GRAY (4)
ORANGE (16)
WHITE (13)
GREEN (8)
BLUE (6)
YELLOW (7)
1
2
RED (14)
3
4
TAN (N.C.)
5
PINK (N.C.)
6
7
8
13
14
N.C.
CONNECT THESE WIRES TO TB 18-19
N.C.
IF CHARGER HAS AN INTERLOCK FEATURE
INTERLOCK (BLACK)
BATTERY
INTERLOCK (WHITE)
CHARGE OUTPUT (RED)
CHARGER
CHARGE OUTPUT (BLACK)
6
5
SUPO-611SPA
REV N
4
2
UP/DOWN
WHITE
10 11 12
13
14 15 16
17
18
19
20
2
BATT + (2 PLACES)
BATT - (2 PLACES)
4
Publicidad
