Marzocchi TENNECO Manual Del Usuario página 28

28
W !
ARNING
The operations listed below accompanied by this symbol
should only be performed by authorized MARZOCCHI service
centers.
General maintenance operation
Check that screws are tightened to required
torque
Stanchions cleaning
Air pressure control
Cleaning and lubrication of sealing rings
Oil seals control
Oil change
Cartridge oil replacement
Fork oil seals cartridge replacement
Table 8 - Periodic maintenance table
Part to be tightened
V-brake locking pins
Fork's top caps
Adjuster locking screws
Pumping rod / cartridge foot nuts
Pumping rod foot screws
Fender fi xing screws (888 RV)
Handlebar clamp fi xing screws (888)
Lower crown fi xing screws (888)
Lower crown fi xing screws (888)
Wheel axle screws
Allen screws for wheel axles
Table 9 - Tightening torques
5 WARRANTY
5.1 Warranty For EU Countries
Subject to the terms and conditions set forth herein, Tenneco
Marzocchi S.r.l. grants an independent warranty to the relevant
end-user that its suspension system is free from defect in material
and/or workmanship throughout a period of two (2) years from
the date of the purchase. A defective suspension system will be
Use
repaired or replaced, at the option of Tenneco Marzocchi S.r.l. free
of charge, within thirty (30) days after receipt of the same from the
Intense Normal
relevant authorized Tenneco Marzocchi dealer. The retail invoice or,
Before every ride
if any, the warranty certifi cate dated and stamped by the relevant
Marzocchi retailer, enclosed with the product, will serve to prove
After every ride
the commencement date of the warranty and the place of purchase
Before
10 hours
of the product. In the event of a defect within the aforesaid term,
every ride
the purchaser should return the product to the Marzocchi retailer
Before Every two
where he/she bought it, illustrating the defect and the reasons of
every ride ride
the warranty claim. The retailer will inform the purchaser when the
product has been repaired or replaced.
25 hours 50 hours
5.1.1.1 NOT COVERED: This warranty does not cover defects
resulting from accidents, alteration, neglect, misuse, abuse,
50 hours 100 hours
improper use, improper assembly, improper maintenance,
repairs improperly performed, replacement parts or accessories
25 hours 50 hours
not conforming to Tenneco Marzocchi S.r.l.'s specifi cations,
modifi cations not recommended or approved in writing by Tenneco
Marzocchi S.r.l. activities such as acrobatics, stunt jumping, ramp
50 hours 100 hours
riding, racing, commercial use, competitive use, use in mountain
biking or BMX parks, use on BMX trails, and/or normal wear or
deterioration occasioned by the use of the suspension system, and,
Tightening torque
in general, all subsequent non- conformity defects resulting from the
(Nm)
non observance of the instructions of the products Manual.
9 ± 1
This warranty does not cover, as they are not original non-
10 ± 1
conformities, items and substances subject to normal wear
2 ± 0,5
occasioned by use, such as oil, sealing rings, dust seals, and
10 ± 1
sliding bushes. In addition, this warranty is void in the event that
the suspension system is used with rental bicycles. This warranty
10 ± 1
will be automatically void if the serial number of the Marzocchi
6 ± 1
suspension system is altered, erased, defaced or otherwise subject
6 ± 1
to any tampering. Finally, this warranty will not cover second-hand
6 ± 1
Marzocchi suspension systems and in this case the retailer will offer
6 ± 1
a warranty for the second-hand product, without liability of any kind,
15 ± 1
either direct or indirect, of Tenneco Marzocchi S.r.l.
6 ± 1
5.1.1.2 TERRITORIAL LIMITATION: This warranty covers all the
products bought only in a EU country (including Switzerland), except
for products bought in a EU country but used in the USA which the
clauses of the "Warranty rest of the world – USA included" apply to.
Some EU countries set mandatory rules which govern the warranty for
consumer goods; should these rules be inconsistent with the terms of
this warranty, national mandatory rules shall take precedence.
Install, service and use the Marzocchi Suspension System
in absolute compliance with the instructions in the products
Manual.
5.1.2 PURCHASER: This warranty is made by Tenneco Marzocchi
S.r.l. with only the original purchaser of the Marzocchi suspension
system, and does not extend to any third parties. The rights of the
original purchaser under this warranty may not be assigned.
5.1.3 TERM: The term of this warranty shall commence on the date
of purchase and shall continue for a period of two (2) years from
the date of the original purchase. Unless the two-year warranty still
applies, replaced parts have an additional six (6) month warranty.
W !
ARNING