Charge Efficiency; Temperature Influence; Eficiencia De La Carga; Influencia De La Temperatura - GAZ KL P Serie Manual Tecnico

Tabla de contenido

Publicidad

Time to reach state of charge at charging voltages for fully discharged GAZ
Tiempo para el estado de carga con tensiones para elemento de Ni-Cd GAZ
1.7
1.65
1.6
1.55
1.5
85 % CHARGED
CARGA 85 %
1.45
80 % CHARGED
CARGA 80 %
75 % CHARGED
CARGA 75 %
1.4
1
2

6.3 Charge efficiency

Eficiencia de la carga

The charge efficiency depends mostly on the state of charge of the
battery and the ambient temperature as well as the charging current.
For much of its charge profile the GAZ
high level of efficiency. But if the battery approaches a fully charged
condition the charging efficiency decreases.

6.4 Temperature influence

The electrochemical behaviour of the battery becomes more active if
temperature increases, i.e. for the same floating voltage the current
increases. If the temperature decreases the reverse occurs. Increas-
ing the current increases the consumption of water and reducing the
current could lead to an insufficient charging.
For standby application it is normally not necessary to compensate
the charging voltage with the temperature. In order to reduce the
water consumption it is recommended to compensate it at elevated
temperature as for example from + 35 °C on by use of the negative
temperature coefficient of – 3 mV/K.
For operation at low temperatures, i.e. below 0 °C, there is a risk of
poor charging and it is recommended to adjust the charging voltage
or to compensate the charging with the temperature (+ 3 mV/K, start-
ing from an ambient temperature of + 20 °C).
(Rango H: límite de corriente 0,2 C
3
4
5
6 7 8 9 10
Charging time [hours]
Ni-Cd battery is charged at a
®

Influencia de la temperatura

Ni-Cd cells (H-Range: current Limit 0.2 C
®
A)
5
20
30
40 50
100
Tiempo de carga [horas]
La eficiencia de la carga depende, principalmente, del estado de la
carga de la batería y de la temperatura ambiente, así como de la co-
rriente de carga. Para la mayoría de su perfil de carga, la batería de
Ni-Cd GAZ
se carga con un nivel de eficiencia alto. Pero si la batería
®
se aproxima a un estado totalmente cargado, la eficiencia de carga
se reduce.
El comportamiento electroquímico de la batería se vuelve más acti-
vo si la temperatura aumenta, es decir, aumenta la corriente para la
misma tensión flotante. Si la temperatura se reduce, ocurre lo con-
trario. Aumentando la corriente, se incrementa el consumo de agua
y reduciendo la corriente la carga sería insuficiente.
Normalmente, para la aplicación de reserva no es necesario com-
pensar la tensión de carga con la temperatura. Para reducir el con-
sumo de agua es recomendable compensar con una temperatura
elevada, como por ejemplo, de + 35 °C o más, usando el coeficiente
de temperatura negativo de – 3 mV/K.
Para el funcionamiento con temperaturas bajas, es decir, menos de
0 °C, hay riesgo de carga deficiente y se recomienda ajustar la ten-
sión de carga o compensar la carga con la temperatura (- 3 mV/K,
empezando desde una temperatura ambiente de + 20 °C).
17
17
totalmente descargadas
®
FULLY CHARGED
CARGA TOTAL
95 % CHARGED
CARGA 95 %
90 % CHARGED
ARGA 90 %
200
300 400 500
1000
A)
5

Publicidad

Tabla de contenido
loading

Tabla de contenido