Measures To Be Taken During Decommissioning; Recommissioning The Truck After Decommissioning - Jungheinrich EKS 314 Manual De Instrucciones

7.2

Measures to be taken during decommissioning

Every 2 months:
– Recharge the battery (see section "Charge the battery" in chapter F).
IMPORTANT Battery-operated fork lift trucks:
Regular recharging of the battery is very important; otherwise, exhaustive
depletion of the battery caused by self-discharging would occur. Owing to
sulphation, this will result in the destruction of the battery.
7.3

Recommissioning the truck after decommissioning

– Thoroughly clean the fork lift truck.
– Lubricate the fork lift truck according to the lubrication chart
(see section "Lubrication schedule" in chapter G).
– Clean the battery. Grease the pole screws using pole grease and reconnect the
battery.
– Recharge the battery (see section "Charge the battery" in chapter F).
– Check if the gear oil contains condensed water and change if required.
– Check if the hydraulic oil contains condensed water and change if required.
– Start up the fork lift truck (see section "Starting up the truck" in chapter E).
IMPORTANT Battery-operated fork lift trucks:
If switching troubles are experienced in the electric system, spray the
exposed contacts with contact spray and remove any oxide layer on the
contacts of the operating controls by repeated operation.
Qw W
Perform several brake tests immediately after recommissioning the truck.
G 17