Spark Plugs - APRILIA RS 125 Tuono 2003 Manual Del Usuario

RS 125 Tuono_Ing_book_my03.book Page 65 Tuesday, April 29, 2003 3:11 PM

SPARK PLUGS

Carefully read page 43 (MAINTENAN-
CE).
Check the spark plug after the first 1000
km (625 mi) and successively every 4000
km (2500 mi); change it every 8000 km
(5000 mi).
Periodically remove the spark plug and
clean it carefully, removing carbon depos-
its; change it if necessary.
To reach the spark plug:
N Lift the fuel tank, see page 57 (LIFTING
THE FUEL TANK).
To remove and clean the spark plug:
N Take off the spark plug cap (1).
Remove all the dirt from the base of the
N
spark plug, then unscrew it with the
spanner you will find in the tool kit and
extract it from its seat, taking care that
neither dust nor other substances enter
the cylinder.
N Make sure that there are neither carbon
deposits, nor corrosion marks on the
electrode and on the central porcelain
part; if necessary, clean them with the
special cleaners for spark plugs, with an
iron wire and/or a metal brush.
N Energetically blow some air, in order to
prevent the removed residues from get-
ting into the engine.
If the spark plug has crackings on the in-
sulating material, corroded electrodes or
excessive deposits, it must be changed.
N Check the spark plug gap with a thick-
ness gauge.
The gap must be 0.7 ÷ 0.8 mm; if neces-
sary adjust it, carefully bending the earth
electrode.
N Make sure that the washer is in good
conditions. With the washer on, screw
the spark plug by hand in order not to da-
mage the thread.
N Tighten the spark plug by means of the
spanner you will find in the tool kit, giving
it half a turn to compress the washer.
Spark plug driving torque:
20 Nm (2 kgm).
The spark plug must be well
tightened, otherwise the engine
may overheat and be seriously
damaged.
Use the recommended type of spark
plug only, see page 79 (TECHNICAL DA-
TA), in order not to compromise the life
and performance of the engine.
N Position the spark plug cap properly, so
that it does not come off due to the vibra-
tions of the engine.
Put back the fuel tank.
N
use and maintenance RS 125 Tuono
65