Regulations To Be Followed During Operation; Maintenance Regulations; Maintenance - Wetrok Speedmatic Tornado Instrucciones De Manejo

REGULATIONS TO BE FOLLOWED DURING OPERATION

– Never sweep up ropes, wire, straps, water, etc.
– To pick up large but light objects (such as paper, leaves, etc.), raise the front flap of the machine by the pedal 10 (fig. 3) slightly for just the time necessary to
sweep the objects up.
– Shake the filters from time to time using the lever 1 on pos. V (fig. 3)
– If the ground to be swept is wet, shut off the vacuum using the lever 1 on pos. C (fig. 3), as otherwise the vacuum filter may be clogged.
– Never pick up glowing cigarette ends or red hot material.
– In presence of a lot of dust it is need to execute afirst phase of cleaning using the main brush only.
– Do not allow outsiders to approach the machine,especially children.
– The machine must only be used by operators authorised by the person in charge of the machine, who are familiar with the contents of this manual.
– These operators must be physically and mentally suitable, and must not be under the influence of alcohol, drugs or medication.
Make sure that:
– There are no foreign bodies (such as tools, rags, equipment, etc.) on the machine;
– The machine does not make strange noises after switch-on; in this case, stop it immediately and trace the cause;
– All safety housings are properly closed, hood and seat support included.

MAINTENANCE REGULATIONS

During cleaning and maintenance of the machine or the replacement of parts, always switch off the motor. Do not use naked flames, do not cause sparks and do
not smoke close to the fuel tank when the filler cap is open, and close to the batteries during charging. Remove the starting key.
!
WARNING! All maintenance, overhaul or repair work must only be carried out by specialised staff or an authorised service centre.
Maintenance (section "i"- petrol version)
Engine
FIG 7 FIG 8
28
Carefully follow the instructions in the HONDA GC 160
OPERATING AND MAINTENANCE manual for all engine
maintenance operations. Always check the oil level in the
engine before starting it up, using the dipstick 3, fig. 4.
Drain the engine oil from the sump drain hose (fig. 7)
every 50 hours work and refill with clean oil.
!
WARNING! Change the engine oil initially
after the first 5 hours work.
If the engine oil level drops below the minimum, a de-
vice inside the engine cuts out the spark to the plug
and stops the engine. If the engine stops unexpected-
ly, check the oil level and top up if low.
Cleaning and replacing the engine air filter
element
Check that the air filter element 1, fig. 8 are in good
working order every time you use the motor-sweeper.
Clean the element 1, every 25 hours work.
!
WARNING! Clean the air filter elements
more frequently if you are working in
particularly dusty areas. Follow the
instructions in the HONDA GC 160 OPE-
RATING AND MAINTENANCE manual to
clean the filter elements.