General Hazards; Exhaust Hazards - Generac GT-530 El Manual Del Propietario

Safety Rules & General Information
The manufacturer cannot anticipate every possible cir-
cumstance that might involve a hazard. The warnings in
this manual and on tags and decals affixed to the unit
are, therefore, not all-inclusive. If using a procedure,
work method, or operating technique the manufacturer
does not specifically recommend, ensure that it is safe for
others. Also, make sure the procedure, work method or
operating technique utilized does not render the genera-
tor unsafe.
WARNING
Only qualified service personnel may install, operate
and maintain this equipment. Failure to follow proper
installation requirements could result in death, serious
injury, and damage to equipment or property.
DANGER
Electrocution. Contact with bare wires, terminals,
and connections while generator is running will
result in death or serious injury.
WARNING
Hot Surfaces. When operting machine, do not
touch hot surfaces. Keep machine away from
combustables during use. Hot surfaces
could result in severe burns or fire.
WARNING
Moving Parts. Keep clothing, hair, and appendages
away from moving parts. Failure to do so could
result in death or serious injury.
WARNING
Moving Parts. Do not wear jewelry when starting
or operating this product. Wearing jewelry while
starting or operating this product could result
in death or serious injury.
DANGER
Asphyxiation. Running engines produce carbon
monoxide, a colorless, odorless, poisonous gas.
Carbon monoxide, if not avoided,
will result in death or serious injury.
1.2.1— General Hazards
• For safety reasons, the manufacturer recommends
that this equipment be installed by a Service
Dealer or other competent, qualified electrician or
installation technician who is familiar with
applicable codes, standards and regulations. The
2
operator also must comply with all such codes,
standards and regulations. Only an Authorized
Service Dealer is allowed to perform warranty
service on this unit.
• The engine exhaust fumes contain carbon
monoxide, which can be DEADLY. This dangerous
gas, if breathed in sufficient concentrations, can
cause unconsciousness or even death. Do NOT
alter or add to the exhaust system or do anything
that might render the system unsafe or in
noncompliance with applicable codes and
standards.
• Install a battery-operated carbon monoxide alarm
indoors, according to manufacturer's instructions/
recommendations.
(000182)
• Adequate, unobstructed flow of cooling and
ventilating air is critical to correct generator
operation. Do not alter the installation or permit
even partial blockage of ventilation provisions, as
this can seriously affect safe operation of the
generator. The generator MUST be installed and
(000144)
operated outdoors only.
• Keep hands, feet, clothing, etc., away from drive
belts, fans, and other moving or hot parts. Never
remove any drive belt or fan guard while the unit is
operating.
•
(000108) When working on this equipment, remain alert at all
times. Never work on the equipment when
physically or mentally fatigued.
• Inspect the generator regularly, and contact the
nearest Dealer for parts needing repair or
replacement.
• Before performing any maintenance on the
(000111)
generator, set to OFF, remove fuses, and
disconnect battery cables to prevent accidental
start up. Disconnect the cable from the battery post
indicated by a NEGATIVE, NEG or (–) first, then
remove the POSITIVE, POS or (+) cable. When
reconnecting the cables, connect the POSITIVE
cable first, the NEGATIVE cable last.
(000115)
• Never use the generator or any of its parts as a
step. Stepping on the unit can stress and break
parts, and may result in dangerous operating
conditions from leaking exhaust gases, fuel
leakage, oil leakage, etc.
(000103)
1.2.2— Exhaust Hazards
• Generator engine exhaust contains DEADLY
carbon monoxide, an odorless, colorless,
poisonous gas. Breathing carbon monoxide can
cause dizziness, throbbing temples, nausea,
muscular twitching, headache, vomiting,
weakness, sleepiness, inability to think clearly,
fainting, unconsciousness or even death. If any
Owner's Manual for 50 Hz Air-cooled Generators