Measures Required During The Shutdown Period; Restarting The Vehicle After Shutdown - Jungheinrich ECR 327 Instrucciones De Servicio

7.2

Measures required during the shutdown period

Every two months:
– Charge the battery (see "Charging the battery" in Chapter F).
IMPORTANT Battery-powered trucks:
Regular charging of the battery is very important; otherwise spontaneous
discharge could lead to total discharge of the battery. This would result in
battery failure due to sulfation.
7.3

Restarting the vehicle after shutdown

– Clean the truck thoroughly.
– Grease the truck in accordance with the lubrication chart
(see "Lubrication chart" in Chapter G).
– Clean the battery. Grease the pole screws with pole grease and reconnect the
battery.
– Charge the battery (see "Charging the battery" in Chapter F).
– Check whether there is condensation water in the gearbox oil and replace it if
necessary.
– Check whether there is condensation water in the hydraulic oil and replace it if
necessary.
– Start the vehicle
(see "Starting the vehicle" in Chapter E).
IMPORTANT Battery-powered trucks:
In the event of contact problems in the electrical system, spray the exposed
contacts with contact spray and operate the controls repeatedly to remove
any oxide film on the control contacts.
Qw W
Test the brakes several times immediately after starting up the vehicle.
G 17