Manual Pre-Cleaning - Anspach eMax 2 Plus Manual Del Usuario

Creutzfeldt-Jakob Disease (TSE/CJD) diagnosis. DePuy Synthes Power
Tools recommends that all Anspach products used on a patient confirmed
with a TSE/CJD diagnosis be incinerated. Anspach dissection tools used
on a patient suspected of TSE/CJD diagnosis must be incinerated.
Contact your Sales Representative for replacement of product incinerated
under this policy or for temporary equipment while original equipment is
quarantined. Contact the DePuy Synthes Power Tools Customer Service
Department regarding TSE/CJD contamination for additional information.

Manual Pre-Cleaning

Warning: Manual pre-cleaning must be followed by mechanical/automated
cleaning.
Detergents
• A neutral pH enzymatic detergent is recommended.
• Alkaline detergents with a maximum pH of 11 may be used but user
must demonstrate their effectiveness.
• The process, detergent and any additives must be discussed with
detergent manufacturer.
Caution: Do not use any alkaline detergent with a pH greater than 11.
Alkaline detergents attack grease and seals which can increase wear and
cause device to malfunction.
Note: Use of alkaline detergents can cause color to fade but this does not
impair function of device.
High Speed Handpieces
1. Preparation
• Remove attachment and dissection tool from handpiece.
• Electric Systems Only: Place electrical cap onto console connector.
(See Figure 1)
• Assemble all necessary supplies including Anspach Cleaning Brush
(ACB), sponge, lint-free cloth and soft bristle brush.
Figure 1
2. Rinse
• Rinse handpiece with distal end pointing down under running cold
deionized, distilled or purified water for a minimum of 2 minutes.
• Use a sponge, soft lint-free cloth, or soft bristle brush to assist in
removing gross soil.
Figure 2
Caution: Do not use high pressure water or air. Do not allow running
water to enter distal end of handpiece. See Figure 2.
3. Manipulate Moving Parts
• Manipulate knurled knob under running cold deionized, distilled or
purified water to loosen or remove gross soil. See Figure 2.
◄
Distal End
Knurled Knob
5