General Information; Guarantee, Safety; Main Statutory Instruments - Cuenod C 280 B 517/8 Manual De Utilización

General information

Table of contents

Guarantee, safety

Main statutory Instruments

Contents
General information
Guarantee, safety .............................25
Main statutory instruments ...............25
Overview, legend...............................26
Packing .............................................27
Technical data
See technical data N° 13013507
Installation
Assembly ........................................28
Gas connection .................................29
Electrical connection..........................29
Fuel oil connection ...........................30
Start-up
Preliminary check-up .........................31
Settings ...................................32 to 38
Program of control
and safety unit ........................39 to 40
Control panel TC ...............................41
Fuel oil firing ....................................42
Settings of the fuel oil pressure .......42
Settings, safety checks ....................43
Gas firing ..........................................44
Maintenance ....................................45
Troubleshooting gas.......................46
Troubleshooting fuel oil .................47
Guarantee
Installation and start up must be carried
out in accordance with currently
accepted practices by a qualified
technician; current regulations as well
as the instructions that follow must be
complied with.
The manufacturer will decline all
responsibility in the event of failure to
comply fully and in every respect with
any of the relevant requirements.
Refer also to:
the certificate of guarantee attached
-
to the burner;
the general terms of sales.
-
Safety
The burner is designed to be installed
on a generator connected to exhaust
pipes used for products of combustion
in serviceable condition.
It should be used in areas where an
adequate supply of fresh air is available
for correct combustion and where any
waste products can be properly
evacuated.
The size and design of the flue must be
appropriate to the fuel in accordance
with current regulations and standards.
+
10
Power supply 230 VAC
%
-
15
to the control and safety unit as well as
to the cut-off devices used must include
an earthed neutral wire.
Failing that, power supply to the burner
must include an isolating transformer
and the appropriate protection (30 mA
circuit breaker and fuse).
The burner must be able to be isolated
from the system by means of
a multi pole switch complying with the
standards in force.
Operating personnel should act with
extreme caution in all cases and more
especially avoid any direct contact with
areas that are not heat-insulated and
electrical circuits.
Water should not be splashed on to the
burner's electrical components.
In the event of flooding, fire, fuel
leakage or any other dangerous
situation (smells, suspicious noises,
etc.), stop the burner, cut off the main
power supply and the fuel supply and
call in an approved specialist.
The use of chlorinated solvents to clean
the burner is prohibited.
It is compulsory for all furnaces and
accessories, flues and connexion
pieces to be maintained, cleaned and
swept at least once a year and prior to
burner start up. Consult the applicable
regulations in force.
Use a purpose-designed foam to test
the external tightness of valve
assembly connections, including the
filter.
11/2003 - Art. Nr. 13 013 506A
Main statutory instruments "FR"
Dwellings :
French Order dated 2
-
1977 and later modifying /
supplementary orders: Technical and
safety regulations governing
combustible gas and liquified
hydrocarbon installations located
inside dwellings and their
outbuildings.
DTU Standard P 45-204 : Gas
-
installations (formerly DTU n° 61-1
- Gas installations - April 1982 +
later addendums).
DTU Standard 65.4 - Boiler house
-
technical provisions.
French NF Standard C15-100 + Low
-
voltage electrical installation
regulations.
French Departmental health
-
regulations.
Public Buildings :
Public building fire and panic
-
prevention safety regulations.
General provisions :
GZ sections (combustible gas and
-
liquified hydrocarbons);
CH sections (heating, ventilation,
-
cooling, air conditioning and steam
±1%
50Hz and domestic hot water production);
Provisions specific to each type of
public building.
Outside "FR"
Refer to local regulations.
nd
August
EN
25